Yamaha Ignition Relay Stop Switch | G16 | G19 | G22 | G29 Drive Golf Cart
Вставка
- Опубліковано 16 чер 2014
- DIY Golf Cart shows how simple it is to replace the Yamaha G16, G19, G22, and G29 "The Drive" ignition relay stop switch. This small part works with your accelerator on your gas golf cart. A faulty switch will result in your cart not performing. Please subscribe to our You Tube channel for other popular videos showing the installation of parts and accessories for golf carts.
- Авто та транспорт
2000,G16A Yamaha, was fine when put away for winter, now not going into forward gear,revese is fine
I had a problem with my 2011 Yamaha gas cart. Thought it solenoid or battery. Battery was old anyway 5-6 yrs. New Battery, helped some. But after checking. Found it highly possible the gas petal solenoid switch was hanging up and not kicking in on the solenoid . Before I spend $$ on switch I removed and rolled back the rubber boot and sprayed blaster and worked the switch for about 10 times. While I was working on that I also adjusted the gas cable there at the petal about 2 rounds. To give a little quicker response when pressing the petal. Tightened it up and replaced the stop switch. Everything at this point seems to be running much better. If the switch starts to hesitate again, I'll purchase a new one at that time.
Thank you for the nice videos ! I have a 1982 yanaha gas golf cart ...it doesn't seem to spin the belt I replace the fuel pump but that is it ! It is a centrifical clutch so how does it make the belt to the transfer case grab !
1st of all, thank you for your videos as they have helped me tremendously.
2nd I have a G29 gas cart that will intermittently turn over. Sometimes you have to hit the pedal a few times or hold it down before the starter engages. After getting it started and going for a ride the battery would die fairly quickly. I just put in a new battery and it still hesitates to start and sometimes won't until I come back another time and try it again. I've checked the ground at the battery and they are good. Any ideas what my problem could be?
3rd Thank you for your time and again for your videos.
I would love to see a video on the full wiring or re-wiring of an older Yamaha gas cart. Maybe a G16 or so. Thanx.
Could you please do a video on Testing / Replacing the Throttle Stop Switch for G29 Yamaha
Finding your videos really useful, Just bought a 2008 Golf Utility vehicle G23A with a Yamaha tipper rear, my intention is to convert this to a Golf buggy with Bag retaining frame. From the 300 miles journey from where I bought it to my place, the Air filter lid has fallen off, I looked online for a replacement but these are just shy of $100! that's a lot to me. I am in the UK and most parts new through EBay are also including Tax and postage making the lid over $180 which seems out of my reach. I wondered if there is a used forum for such parts? or if you know an alternative to my problem, I also only have ONE of the spring clips to hold the lid on - really wish the seller had put it in the bag with the other loose bits :( One other point, it does look like the chasis is longer than the golf cart chasis, If I replace the cowling (assuming I can find one) do I need to start cutting and welding the frame, if so where? Regards
Chris
I have an EZ go that keeps running the start motor sometimes. Not all of the time but just now and then. I'll pull up to my garage and the gas engine stops but the electric stater/alt keeps going. I believe it has drained the battery also. Ive had to recharge the battery from dead twice now. Any thoughts?
I have what i believe to be a Yamaha G2. It turns over with the key but no spark. If i put 12 volts directly to the starter relay coil it does however start. I have checked the key, pedal switch and low oil sensor and all seem to be working fine. Could this relay stop switch be the issue? Thanks in advance
I have a 2002 G22a gas burner that will not shutdown when I lock the brake pedal down. If the engine is cold it will eventually lope along and shutdown. If it’s warm I have to pull the spark plug or hold down the brake pedal and pump the accelerator until it floods out (I guess). I have changed every part out i can think. A trouble shooting video would be cool. Thanks in advance.
I have a Yamaha 1999 G16E, someone had there hands on it, before I got it, It seems to go faster in reverse than foward, could it be the wires were reversed on the forward / reverse switch ,or on the motor?
Thank you for the videos! I've watched a few already this morning and they've been great. I have a 2011 G29 Gas that won't stay running after it warms up. Starts fine and seems to have plenty of power when it's cold, but as soon as the motor starts to get warm it loses power and chokes out. If we let it sit for a few minutes to cool down it will run again for another minute or so then sputter and die again. Thoughts? Cart has no modifications done to it.
diygolfcart.com/yamaha-g16-g20-g21-g22-ignition-coil/ We do have it in stock! Call to place the order.
Did you say that this stop switch is what grounds the engine out, and will cause it not to SPARK?
I have a 2000 Yamaha G16A golf cart after we are driving it at night with the lights on for a few miles when we come to a stop the engine quits running. Headlights bright turn signals working and when put into reverse the warning buzz is loud and clear. We will let it sit for 5minutes or so and then it will start up and drive fine. I could use help, Thank you
Need some advice on early 80's Yamaha golf cart motor can't remember what wire coming off starter to battery battery to relay switch is anybody will be cash help me get run again
Trying to install ignition switch that has no plug?
Can u advise? Supply plug?
I have an inline fuse that has blown twice and I'm not sure why it does that, but nothing works when it does, any idea why that would be? It's in the cover box with the solenoid and regulator.
I have a 2012 Yamaha Modle YDRAX3 PTV I'm getting fault code 45 which I believe is for a stuck VM Relay. Where is this relay located?
Ive got a 1996 Yamaha g16 and the cart just quit while driving. No power what so ever. Ive checked wires and battery. Any help would be great!!
My engine did this once but no more. I had intermittent pedal clicks the solenoid but doesn’t go. Then a few pumps it’s go. No power leaving the solenoid so is that the issue or volt regulator or stop relay. Does the stop relay only tell the engine that stop?
Hi. I’m looking for some help. I just hooked up battery tending cables on my mother in laws 2019 Yamaha EFI so she would just have to plug into it when she leaves for the summer. I did it last year and no problem. Someone removed them six months ago and it’s been running fine the entire time. We used it all week. After I installed them last night we left and drove back to Boston. She called me on the way home and it won’t move in forward or reverse. There is power to the battery because the horn and all of the lights are working. Any idea what could be going on? Ty
My 2001 G16 will not suck the air to make the fuel pump suck the gas out of the tank, any ideas?
what should be the ohms on the start relay
I got a 2001 fuel injected Yamaha golf cart that will not turn over the battery is good the pedal switch is good the starter is good the belt is good I can get the starter to turn jump in the solenoid but it will not start any clue what to look for next.
2021 yamaha golf cart back lights wont turn off.. right after i rinse it off
Will it stop it from rumning
I have a 2000 Yamaha g16a. Most of the time runs and start right up. Then other times it just rolls over and wont start. Its getting gas. Just isnt getting spark. What would be doing that. Celenoid clicks and so does the engine stop switch.
My G29 has no spark, any advice? I'm fixing it myself
hello, could you help me I have a yamaha g29 cart the problem it has is that it starts but it doesn't go very far and it turns off completely and until I press the circuit breaker it starts again but it does the same thing and I can't find what it is could you help me
I could not find a video that explains how to replace the rear axle bearing. Is there one available?
Unfortunately we haven't done that video yet.
I have a 2006 Yamaha G22A - new battery. lights, horn turn signals all work. When i turn key to on and do the reverse lever - no beep, and when i press the accelerator pedal to go - no action at all - is this a fuse? What fuse would/could it be and where is it located?
There is a black cover on the drivers side under the seat being held in place with a 10mm bolt. The fuse is located under it.
How do I know if my relay is still good? Thanks for your videos!
When the Engine Stop Relay goes bad, the golf carts engine will not shut off when the pedal is released. When you take your foot off the pedal and the engine stops, its working.
@@diygolfcart Can the stop switch also make the engine not start? I have spark and fuel. It turns over but wont try to start???
@@summitpointauto3463 Absolutely. The stop switch is what send positive voltage to the solenoid to engage to turn the starter over.
@@summitpointauto3463 Did replacing this engine stop switch solve your problem? I have the exact same problem, spark, fuel, starter engages and turns over engine, But engine doesn’t start. DIY golf cart’s answer was ambiguous, because he said it’s what sends the voltage to the solenoid to engage and turn the starter over, but in our cases, the starter IS turning over.
@@diygolfcart where can I get this part? I cannot locate it anywhere.
Yamaha YDAK. Sometimes it cranks just fine when you hit the pedal. Then all of a sudden it does nothing when you hit the pedal. All connections are good, battery is good, grounds good.. Interment problem. What next?
I’m trying to hook up a voltage reducer to my g29, what wire is the vehicle key switch?
I see a lot of questions on here and no response from this guy. Well that's that
Vet
Hi, what should the engine compression be on a g-16 Yamaha golf cart with original engine 1999?....Thanks
Should be around 145 lbs, not lower than 125 lbs.
Thank you very much, ya'll are great
I have aG16 that suddenly won’t start but stop solenoid clicks when I push pedal .what else would suddenly make it not start? Fuse is good.
I have the same problem. Did you figure out how to fix it?
Nicole Rishel yes it turns out that my battery suddenly died. After a couple hundred dollars in new parts put in a new battery and it started up just fine.
@@toddlamarr1553 Thanks for the reply...my battery is brand new. Too bad about the parts $...I also spent over $100 on a new starter and that wasn't it either
My battery was a year old. Under the seat on drivers side there is a black box. In that box is the start stop relay and a inline fuse. This relay is known to just go . Check your battery under load.
I have a Yamaha g16, runs extremely slow. (2mph) , replaced carb, fuel filter, fuel lines and spark plug. Any suggestions on what’s wrong? Thanks
Check the governor with the pedal pressed down and see if it moves. The cable from the pedal to the governor may be broken.
I have a 2000 Yamaha gas burner and when I press the gas over half way, it goes dead. Any suggestion to the problem?
Check the main jet in the carb.
Why does my golf cart have two 12v 60a relays?
I have a 2005 Yamaha g22a gas cart. My son was driving it one day and all of a sudden, it simply quit. Press the gas pedal and nothing. Checked both fuses and their fine. Doesn't even kick or try to start. We were previously told it was the solenoid so we replaced that. Still nothing. Any ideas?
With the key "on", in forward, depress the accelerator pedal and see if you're getting voltage on the 2 small terminals of the solenoid. If not, bad accelerator pedal switch.
I have a 1988 Yamaha golf cart and when i turn off the key the battery light stays engaged is that normal or do I have a switch problem
If you are referring to a battery charge indicator on an electric golf cart, then yes, they will stay on. They are LED's and will not effect your batteries performance.
My Yamaha golf cart runs about half throttle and then it acts like the governor kicks on. Before this it ran fine. Do you know what could be the problem ??
(1) Check the throttle adjustment to the carb. (2) Make sure that you have a nice Blue Spark and that it's consistent.
It was a fuse all. The solenoid was bad jumping it to get it from the barn to the house must have blown it. :-/
My Yamaha G2 is having starting problems, I have replaced the starter, solinoid and battery cable ends. It works fine sometimes then will not turn over. I can hear the solinoid clicking but will not turn over. Battery has 12.8 volts at battery and at solinoid. Where do I go from here? Is there a relay somewhere that may be the problem?
If the solenoid is clicking yet the starter isn't engaging, check he brushes in the starter generator.
@@diygolfcart The starter is brand new, I replaced it about a month ago.
I also replaced the battery cable ends. Seems like the power is not getting to the starter
Is there a relay in between the solinoid and the starter? What do the two small wires off if the starter go to? There are also two small wires on the solinoid. With my golf cart it will not start and it does the clicking and if I wait a hour and come back it will start right up again? Very confusing.
Hi im hoping you can help me, i own a Yamaha G29 gas golf cart. The issue i am having is that when i put for down on the accelerator pedal there is a lengthy delay before the cart actually starts to move. This seems to get worse the warmer the motor gets. Near the end of a round of golf the delay can be as long as 5 seconds or so. I have friends who own identical G29's and theirs do not do this. Is there a solenoid or something that could be faulty? Any information would be greatly appreciated :) keep the video's coming they are great. Jason
when i push down*
The most common issue with this symptom is, worn brushes in the starter generator. Take the rubber boots off the back end and blow out the interior of the starter as a first step. (Carbon Build Up) If this doesn't work, I see brushes in your future!
Cheers Barry I have checked the brushes and the are fine. Is there anything else it could be, it doesn't seem to be getting any worse just very annoying. Thanks
the1knightrider1 Does the Solenoid engage as soon as you depress the accelerator or is there a delay there also? Could either be a bad solenoid if it's getting power and not engaging or bad connection in the accelerator stop switch. If you want to go into further details, call me at 855-349-4653
@@aarongouldie1412 I have this many the solenoid clicks. No volts leaving it. So assume the solenoid is bad
I have a 1996 G16 Yahama golf cart that continues to burn spark plugs, Change to a new plug and it will run for about twenty minutes and we need another plug, Can anyone explain why this could be happening?
What type of spark plug are you using? Use a hot plug (low number) and also check the coil and make sure you have a good blue spark!
g22 yamaha golf cart
I have a 2019 G29 EFI wont start, Everything checks out fine, every fuse, relay, solenoid, etc.
When the key is turned on I have 10V power to the fuel pump plug, but nothing to the fuel pump terminals inside the lid of the fuel pump, for some reason??? I can't get voltage to read on the inside of the fuel pump lid, If I jumper the fuel pump nothing happens,
Yes, I need help..
Did you solve this issue with your fuel pump? I have the same problem
I have a g-11 yamahauler. The starter relay is buzzing and it doesn't go. Anyone know what is wrong. We thought it was the starter relay, replaced it, same vibrating noise and no go.
Sounds like either a bad battery or a bad solenoid.
DIY Golf Cart we replaced can the solenoid and starter relay. It'll jump and run!
Key "on", in "forward" depress the accelerator pedal, are you getting 12 volts on the 2 mall terminals? If not, bad accelerator stop switch.
Thanks we'll try that next. fingers crossed LOL
can any one help me 2000 yamaha gas G 16 i thought the coil died. changed coil very light spark changed key switch still the same hrs of working on it HELP PLEASE
What type of spark plug are you running? Hopefully a NGK!
yes i am with my spark tester very light spark nothing at plug
@@skullybiker Unfortunately the only thing else that will contribute to a weak spark will be the coil. The newest one may be bad also, it happens.
TURNED OUT HAD TO BUY ORIGINAL COIL AFTERMARKET WILL NOT WORK .... THANK YOU ALL
Sometimes I have to press Excelerator a couple of times to go
Is the solenoid engaging each time?
I have a Yamaha 2001 G20 (I think) cart. Problem is that you push the pedal and maybe nothing, maybe a little turn but no start. Push it 4, 5 or so times and it will finally start. Sometimes it's as though nothing and sometimes it will crank and hold until it starts. In the winter and colder months it is worse. Looking for the likely culprits. Solenoid? Starter Generator? Stop switch? Hoping that you can help.
Two things that could be the culprit, weak battery or worn brushes in the starter generator. Check the voltage of the battery while trying to start the golf car and make sure it doesn't drop below around 11.5 volts. Then using a air hose, try blowing the starter out by removing the rubber plugs on the backside. If that doesn't help, change the brushes.
DIY Golf Cart does any know how to check charging system for yamaha g16a, 2001 or wiring at starter generator
Here is a link to a video of what it is doing
ua-cam.com/video/RHfvF3lyizk/v-deo.html
my gas cart runs fine till it gets hot then it quits
Bad coil