Це відео не доступне.
Перепрошуємо.

Kohler Courage XT Lawnmower Engine wont start FIX

Поділитися
Вставка
  • Опубліковано 23 кві 2017
  • If your lawnmower has one of these kohler courage XT engines and it won't start after sitting for the winter, try this

КОМЕНТАРІ • 30

  • @lazylimey4754
    @lazylimey4754 3 роки тому +1

    Bought a Koehler mower from Home Depot and it never starts in the spring.I too believe it is the Ethanol(Corn Syrup) in the gas but even putting 94 Octane does not help. I take the bowl off the carb and then put a “Bendy Straw” up into it and blow hard three or four times and that clears the needle jet. Works the rest of the Summer ok.should not have to do this but it has worked for the last 7 years. TR

    • @machinesnmetal
      @machinesnmetal  3 роки тому +1

      That is AWESOME! 😅
      Can you please please please make a video of this???

    • @lazylimey4754
      @lazylimey4754 3 роки тому

      @@machinesnmetal I will try to make a video ASAP. I always meant to as it was an easy fix

  • @Nate1984Mac
    @Nate1984Mac Рік тому

    Thank you very much! God bless you!

  • @danielneel2856
    @danielneel2856 Рік тому

    Pull the gas line off from the tank,look in the gas hose and the probably be a yellow colored round piece of plastic. That is the end piece that holds your gas cap from falling in the dirt when you fill your tank. That plastic piece is restricting the flow of gas to the carb. Pull it out, throw it away, re-attach the hose back to the gas tank, and you are mowing again. I have had 9 of these mowers in my shop and 8 out of 9 times this was the problem.

    • @machinesnmetal
      @machinesnmetal  Рік тому

      I think that you are describing the fuel strainer. You need it to keep the dirt from getting into the carburetor

    • @michaelvoland3625
      @michaelvoland3625 Рік тому

      Wow! I just did what you said. When i pulled the line off I saw this plastic piece in the line. I pulled it out, put the line back on, put gas in tank and wha-Lha! Started on the first pull! Thanks man. I would have never thought of that on my own.

  • @ryanmullen4482
    @ryanmullen4482 6 років тому

    So I have one of these and it was so bad the piston was rusted into the crank case so I freed it up and it’s all back together and I can’t get it to start for the life of me what other pointers do you have for me

    • @machinesnmetal
      @machinesnmetal  4 роки тому

      trade it in at the scrapyard for a runner and give it a tune up

  • @stevesterling6514
    @stevesterling6514 Рік тому

    Ever have one where it was hard to start after getting hot? Or not starting even after a clean/ replacement of the carb?

    • @machinesnmetal
      @machinesnmetal  Рік тому +1

      Your choke is most likley stuck closed

    • @stevesterling6514
      @stevesterling6514 Рік тому

      @@machinesnmetal do they stick stuck or is it the vaccume part thats garbage?

    • @Steven-gv1ke
      @Steven-gv1ke Рік тому

      ​@@stevesterling6514the metal piece that bolts to the exhaust and has a bar linkage that runs over to the carb is probably trashed. They go bad. It's like $15 for a new one. It's one of the most common failures on these. Also make sure to clean all the linkages where the metal rods meet the plastic pieces and make sure they move easily and freely. Also clean and lubricate the hinge on the butterfly throttle plate as well. Check the fuel line for obstructions, as a common issue is part of the gas cap falling into the fuel line. You can buy a china made carb for $20. The Kohler ones are $40 now. Run startron fuel stabilizer to minimize ethanol effects and prevent gumming and keep the carb clean. I just pour a few ounces in each 5 gallon gas can.

  • @richardhyde6418
    @richardhyde6418 5 років тому

    Thanks for posting...

  • @TraumaChaplain
    @TraumaChaplain 5 років тому

    how do you know if it is the carb vs the coil pack...any troubleshooting clues?

    • @machinesnmetal
      @machinesnmetal  5 років тому

      squirt some gas in the carb under the air filter, if it starts and dies the coil is fine, it's a fuel issue.

    • @TraumaChaplain
      @TraumaChaplain 5 років тому

      @@machinesnmetal thanks for the response. I had cleaned out the carb and it ran for about 45 minutes and after refilling the gas tank, I couldn't restart it and then ran across your video which made me think.

    • @machinesnmetal
      @machinesnmetal  5 років тому

      perhaps if your machine has an autochoke it isnt working properly

  • @binujoseph2716
    @binujoseph2716 5 років тому

    Can u send the link for the amazon link

    • @machinesnmetal
      @machinesnmetal  5 років тому

      www.amazon.ca/AISEN-Carburetor-Filter-Courage-Engines/dp/B075H8T4WT/ref=sr_1_4?keywords=kohler+carburetor&qid=1564376350&s=gateway&sr=8-4

  • @bobjoh1
    @bobjoh1 7 років тому

    Your video helped. My Kohler Courage XT7 173 lawnmover had a fouled carburetor bowl and the pins needed cleaning....again from fouled gas. I wasn't able to find a carburetor from Amazon. Can I buy one from you?

  • @joshuainnis7123
    @joshuainnis7123 6 років тому

    Can you send link to new carburetor on amazon?

    • @machinesnmetal
      @machinesnmetal  4 роки тому +1

      www.ebay.ca/itm/Carburetor-For-Kohler-Courage-XT6-XT7-Carb-14-853-21-S-14-853-36-S-14-853-49-S/323943626289?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m2749.l2649

  • @peterngo2130
    @peterngo2130 3 роки тому

    Do you have the part no. for the carburetor? Thanks

  • @NinjaXagor
    @NinjaXagor 3 роки тому

    Well, that answers that I guess.

  • @anthonythompson4718
    @anthonythompson4718 7 років тому

    i just cleaned my fucking carb didn't work i will buy a new one thanks

    • @machinesnmetal
      @machinesnmetal  4 роки тому

      www.ebay.ca/itm/Carburetor-For-Kohler-Courage-XT6-XT7-Carb-14-853-21-S-14-853-36-S-14-853-49-S/323943626289?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m2749.l2649