Great video! These renault engines are actually pretty easy and cheap to service in my opinion! I‘d really be interested in seeing you servicing the injection system, as thats actually something i havent done myself on these yet
Yesterday i changed the fuel filter with your help. Mine has rear secondary air conditioning unit and it is a little bit different the way to do it but i did it. Thanks.
Good video mate, keep them coming theres a real lack of videos on the 1.6 vivaro/traffics which seeing as they seem to have so many problems is strange, I have a 2016 145 biturbo and I'm always worried there's something up with it
Thanks fir the comment , should have plenty more to follow.. look after a few of them! the turbos are mega common but doing a video would be bit tricky! ha
Great video thanks doing my vivaro soon ...I was going to do the sump plug to 20 NM ,read on internet,but think I'll go with the 50 NM you say :) Cheers mark
Of corse Renault will only sell you the full fuel filter housing,,Because they can charge you 50 quid for them,,Insted of the 5 or 6 quid you can buy the filter eliment inside...
Are you sure you connected the couplings in right connections? The middle connection is going to the engine(clean fuel)? And the outer connection is coming from fuel tank(not clean fuel)?
Great video. Do you have any videos on the location of the dpf on a vivaro b? I can’t find it anywhere. I’m guessing it’s behind the tray you took off in this video. Thank you
Me again , lol . Brought a wireless reverse camera , camera wat goes to the reverse light there is 3 wires goes into one plug back of the light down no which two colours I need to conect to ? Cheers
Hi. Do you know where the thermostat is and is it a front off job. I've searched high and low. No one seems to know or not willing to help. Thanks Christian
Have a check round all the pipes that are high up , there may be a bleed screw in one of them .. if not run it was the header tank cap off for about 10 minute.. keep the heater on full blow and full heat ; once it’s getting up to temp the air should be out
@@snappyfish no,, just don't leave your add blue go below 30%, on your trip computer,, I've worked for Renault 6 years, 1.6 are a load of rubbish, egr valve show me a most of them before 30000, clutch master cylinder which is located above the clutch pedal changed within months of new vehicles, bottom crankcase pulley oil seal leaks within 10000 miles, I would challenge anybody to take their undercover tray off and you will see the oil leak on vans that's done 7000 miles, workshop we only work on vehicles that are under warranty, shocking
Great video 👍👍. Do you know what the service intervals are and what needs to be changed? I bought my 2018 Trafic second hand and know it has one service (oil+oilfilter) at 12400mls. Now it has almost 19000mls and i like to know when it's time to do the next service and what's needed. I already ordered all the parts you replaced so i can do that . Thanks for the info.
Thanks for the comment, much appreciated 👍 officially the intervals are every 25,000 or 2 years (which ever comes first) but personally I think that's way too long! We say every 12,500 miles or a year.. The engine oil certainly wants changing every 12,500 miles at a minimum.. they are very prone to turbo failure through oil starvation due to poor quality oil.. keep the oil changes up an you shouldn't have much bother 👍 The fuel & air filters are officially due at 50,000 / 4 years but again id be doing them at 3yrs / 37,500 max
@@diydaly Thanks for the information. I'm going to replace all these parts at 20,000mls and take that as a starting point. Then every 12,500mls at least oil and filter (this is about once a year for me). Keep up the good work 👍👍
@@curtraaymakers6777 yeah that’ll be ideal mate .. you definetly want to get the complete fuel filter housing rather than just the element 👍 purflux do an aftermarket one
@@diydaly Its the timing chain cover, the sealant from factory is crap and it breaks down.. Renault had my van in for repairing it and engine had to come out less than 12months later its leaking again
@@brownsadventures312 still not had it back yet, had quite a few leaking from the side cover but I think this one was from one of the turbo oil feed pipes
Check Euro car parts for filters etc - tidd.ly/3lIO7xA (use discount codes on site)
Check "Car Parts for Less" - tidd.ly/2LNEwIn (use discount codes on site)
Oil & filter kit Ebay - ebay.us/yar0YC
Air filter Ebay - ebay.us/AkFKsk
OE Fuel filter housing Ebay - ebay.us/TQgiiv
4L Engine oil amazon - amzn.to/3ujyWPp
Brake cleaner eBay - ebay.us/57pfYI
Purflux fuel filter housing part no - FCS922
Tools :
3/8 Digital torque wrench - amzn.to/2PP9vpP
3/8 standard torque wrench - amzn.to/33eZsxj
Socket set - amzn.to/3eGx2Ak
Brake cleaner sprayer - amzn.to/2BLF1gX
Long reach 3/8 ratchet - amzn.to/3iJsADg
Ring Inspection Lamp - amzn.to/3gGWHcG
torx screw driver set eBay - www.ebay.co.uk/itm/142442401623
Pic set - amzn.to/33JcZyJ
Dewalt 3/8 impact driver - amzn.to/3njemLY
Screwdriver set - amzn.to/3jswgJP
Snap on mini flat blade screwdriver - ebay.us/grHTHT
Sump plug removal tool set - ebay.us/vfIbRq
Mole grip set - ebay.us/EMIJrq
7mm hose clip tool - ebay.us/wJjmgj
The fuel filter looks like the original - respect for changing it - as many have neglected it before you.
Yeah it was one of the worst id seen! ha
I like the oil filling tip . Took me ages to put a litre of oil in my vivaro . Like watching paint dry
Thanks for the comment! yeah its bloody steady otherwise haha
Great video! These renault engines are actually pretty easy and cheap to service in my opinion! I‘d really be interested in seeing you servicing the injection system, as thats actually something i havent done myself on these yet
Thanks for the comment, I look after a few so will have more videos to follow 👌👍
Yesterday i changed the fuel filter with your help. Mine has rear secondary air conditioning unit and it is a little bit different the way to do it but i did it. Thanks.
are never come across that before, glad it helped 👍
Thanks for the vid, just ordering oil and filters from your links, spot on! Ive got a MY18 125hp version (R9M452), 20k miles, so far so good.
Nice one , thanks for the comments .. glad to help 👍👌
Superb video thanks, great to see a self priming tank for the change of the fuel filter.
Glad you enjoyed it, thanks for the comment
Thanks so much for this. So helpful. UA-cam at its best.
Good video mate, keep them coming theres a real lack of videos on the 1.6 vivaro/traffics which seeing as they seem to have so many problems is strange, I have a 2016 145 biturbo and I'm always worried there's something up with it
Thanks fir the comment , should have plenty more to follow.. look after a few of them! the turbos are mega common but doing a video would be bit tricky! ha
Thanks from Spain
You're welcome! thanks for the comment 👍👌
Great video of this vehicle service and explained brilliantly !!
👍👍thanks
Fantastic video ! Thank you for going to all this effort !
Glad to help 👍👍
Great video best one seen so far on the viv 👌👍
Glad you liked it, thanks for the comment , much appreciated as a small YT channel 👌👍
@@diydaly liked and subscribed 👌👍
@@CrfrDixie 😃👌👍
Great video thanks doing my vivaro soon ...I was going to do the sump plug to 20 NM ,read on internet,but think I'll go with the 50 NM you say :)
Cheers mark
Thanks for the comment mark , glad to help 👍
Of corse Renault will only sell you the full fuel filter housing,,Because they can charge you 50 quid for them,,Insted of the 5 or 6 quid you can buy the filter eliment inside...
magic stuff very helpful thanks very much
You're welcome!
A spectacular video. thank you very much for being so professional
Un video espectacular. muchas gracias por ser tan profesional
Glad to help , should be lots more to follow 👌👍 thanks for the comment 😁
Are you sure you connected the couplings in right connections?
The middle connection is going to the engine(clean fuel)?
And the outer connection is coming from fuel tank(not clean fuel)?
Hi mate any chance you could show how to change alternator belt no videos of new shape for some reason
Yeah if I get chance I’ll do one next time I have one in! 👍👍
Make life easy cut holes in the undertray to access drain pluv and filter with no need to remove the tray
Hello very good video I look your other video thank s you
Thanks for visiting 👍
Great video. Do you have any videos on the location of the dpf on a vivaro b? I can’t find it anywhere. I’m guessing it’s behind the tray you took off in this video. Thank you
it sits right behind the engine block
Thanks very helpfull 👍👍👍👍👍👍
You're welcome 👍
Thanks a lot!!!💪
Complimenti Great video thanks to italy
Thanks for watching!
Me again , lol . Brought a wireless reverse camera , camera wat goes to the reverse light there is 3 wires goes into one plug back of the light down no which two colours I need to conect to ? Cheers
im not sure without looking tbh mate, Ill have a gander if we get one in this week
Good thorough vid that. Like it. 👍
Glad you enjoyed it! Thanks for the comment 👍👌
Did you know what that oil leak was as have same problem when doing my oil change
im afraid it never came back in for it in the end mate!
Thanks a lot for your vid
Thanks for the comment , glad to help 👍
Hi. Do you know where the thermostat is and is it a front off job. I've searched high and low. No one seems to know or not willing to help. Thanks Christian
I’m sure it’s located on the front , but awkward to access and you’ll need some of the front end off by its easy to strip
Excellent.. thank you.
You are welcome!
Any idea why the drain plug torque is 50nm? Seems high compared to most other cars.
Yeah just the recommended, ive known a few similar just depends on the size thread/pitch etc & the type of metal they are going into
hi great vid mate what size socket do I need for the oil filter ?
Hi mate, it was a while ago I did it but thinks it’s 27mm
As always, great video. Clear and informative. Just a quick question. Is this the same service for a 2013 Vivaro 2.0 CDi
Thanks 😁👍 2013 2.0 will be a little different mate , I’ve got one to do in the next few months so hopefully get one uploaded 👍
How do I bleed the cooling system on this vehicle
Have a check round all the pipes that are high up , there may be a bleed screw in one of them .. if not run it was the header tank cap off for about 10 minute.. keep the heater on full blow and full heat ; once it’s getting up to temp the air should be out
Hey, i have a question, Is it not necessary to bleed the system after replacing the fuel filter?
Neh I never do with that style pump 👍 it has a pre pump in tank and soon forces the air out
Great video
Thanks!
Quick question renault traffic 2015 crewcab, won't go in gear when started ? But goes in gear when engine is off
Clutch fault I’m afraid mate 😖 could be the clutch it’s self , the clutch slave cylinder or the master cylinder
@@diydaly OK cheers only just got it yesterday aswell got 3month warranty on it
@@andymethley2298 are that's lucky then! as could be quite costly otherwise 👍
Well it's been back for a new clutch apparently
@@andymethley2298 👍
nice video good job.
Thanks!
Great job
Thanks Alex 😀
Was that making a "ticking" sound on startup? Mine does this for 5 to 7 seconds?
Hi garry I can’t remember it too well as it was a while a go but seem to think I’ve had a few sound similar
That's your ad blue pump spraying that into your exhaust system,
@@1971dave Thanks for that. Is it fault?
@@snappyfish no,, just don't leave your add blue go below 30%, on your trip computer,, I've worked for Renault 6 years, 1.6 are a load of rubbish, egr valve show me a most of them before 30000, clutch master cylinder which is located above the clutch pedal changed within months of new vehicles, bottom crankcase pulley oil seal leaks within 10000 miles, I would challenge anybody to take their undercover tray off and you will see the oil leak on vans that's done 7000 miles, workshop we only work on vehicles that are under warranty, shocking
Thank you!
Thanks for the comment , glad to help 👍
hi...what kind of engine is it? displacement? thanks
1.6 cdti mate
Great video 👍👍. Do you know what the service intervals are and what needs to be changed? I bought my 2018 Trafic second hand and know it has one service (oil+oilfilter) at 12400mls. Now it has almost 19000mls and i like to know when it's time to do the next service and what's needed. I already ordered all the parts you replaced so i can do that . Thanks for the info.
Thanks for the comment, much appreciated 👍 officially the intervals are every 25,000 or 2 years (which ever comes first) but personally I think that's way too long! We say every 12,500 miles or a year.. The engine oil certainly wants changing every 12,500 miles at a minimum.. they are very prone to turbo failure through oil starvation due to poor quality oil.. keep the oil changes up an you shouldn't have much bother 👍 The fuel & air filters are officially due at 50,000 / 4 years but again id be doing them at 3yrs / 37,500 max
@@diydaly Thanks for the information. I'm going to replace all these parts at 20,000mls and take that as a starting point. Then every 12,500mls at least oil and filter (this is about once a year for me). Keep up the good work 👍👍
@@curtraaymakers6777 yeah that’ll be ideal mate .. you definetly want to get the complete fuel filter housing rather than just the element 👍 purflux do an aftermarket one
24mm doesn’t fit for the filter housing
Mine is an R9M 452 engine at it does 7.4 liters. 1.6 biturbo 125hp
👍
Hello, what size is the square driver for the sump plug?
I’ll try find out for you Tom, they come in a set .. will have a gander today
8mm
Yea I can’t undo mine ither …. Nothing fits and it’s not 8mm
why would a manufacturer put a filter on the underside of a vehicle where it could rust
Lol they seem to come up with these daft ideas 🤣
hi...type of motor? thanks
1.6 cdti mate
Great video ,Did you find the oil leak ?
Thanks Mike! Not yet mate , I’ve got it coming back in next month to have a gander see if I can find it 👍
@@diydaly Its the timing chain cover, the sealant from factory is crap and it breaks down.. Renault had my van in for repairing it and engine had to come out less than 12months later its leaking again
did you sort the leak on this one mate?
@@brownsadventures312 still not had it back yet, had quite a few leaking from the side cover but I think this one was from one of the turbo oil feed pipes
@@diydaly are they easy to re seal the cover with engine in situ or best to remove engine ?
How many liters of oil does this car take?
6 Litres mate
I thought these take 7.4 litres?
@@iansteward9193 depends on the engine code mate , some are 7.4 , think the difference is single or twin turbo models
@@diydaly yeah mines a bi turbo defo 7.4 litres 😀
@@iansteward9193 👌👍
AUTO-VOX CS-2 Digital Wireless Reversing
will check the kit out too
Nice torque wrench! 😂
Quick question when changing gear sometimes the clutch stops further down other times it pops up bk to normal.. I that normal
No mate I’m afraid that could be a fault with your clutch slave or master cylinder 😬