Makes me apprehensive to buy a used car in case the owner followed those ridiculous manufacturer oil change intervals. They don’t care about your car as long as it makes it out of the warranty period!😔
The BMW dealer thought I was crazy for not following the 15k mile rule on my 335i. Never would I run a $20k engine that long on oil that costs $60 to change.
@@slscamggood man my 335 just spun a rod bearing 5 thousand kilometres after buying it im assuming since the previous owner did not keep a proper oil change interval on n54 super sad ngl
You can change the oil every day and fill with the most expensive fuel, but that will not save you from the carbon deposits that are the result of direct injection
This is why I do a fuel system service every 5k along with synthetic oil and 87 octane per owner's manual on my 2021 Hyundai Sonata Limited 1.6 T. Other maintenance items would include tire rotate and balance. 4-wheel alignment every 2 5k oil services.
@@jeffreycheng5984 fuel system service has no impact on direct injection, except maybe keeping combustion chambers cleaner. Valve are not touched by gasoline - extended oil change intervals CAN impact them due to oil vaporization/evaporation.
@@KM-ol5bs Ford uses on the Coyote (5.0)- the port injection is only used under high load, intake ports still get nasty- a 100k Coyote has valves and ports like a 40-50k DI engine. Good Oil is key. Not quick lube/Walmart cheap oil changes!! (Those ever, not just DI). QUALITY synthetic oils changed 5-7k will drastically reduce the garbage in the intake and ports/valve... Drastic as 25-40% improvement... Oil catch cans DO help... Again QUALITY IS KEY... Cheapest on Amazon/eBay is not going to do the trick....
@@ayayoutuber VW took out the dual injection that the euro cars have that pretty much eliminated this problem... but its also part of routine maintenance... so as long as you get the valves cleaned every 60,000 miles is not a big deal. Many earlier direct injection systems did this the newer vw's it's not as bad.
Was about to say the same thing. Oil change intervals and quality of has don’t have anything to do with DI carbon buildup. This would have happened even if the oil was changed every 5k and premium gas was used.
The CC is the type of car that will absolutely punish you for giving it anything less than premium fuel & synthetic oil every 5k miles at the most. The problem is that the older ones can be picked up for about $4k now and the people that do are going to treat them accordingly
@nomenclature9607 haha I was about to add in my original comment that with a Camry you can get away with using low grade gas and being stingy on oil but never a turbo VW
@nomenclature9607 Not everyone wants a Toyota Camry and the owner of this vehicle could have avoided the repairs if they followed the manufacturer's maintenance and fuel requirement recommendations.
@@Rextraordinaire German engineering is overly complicated and not too robust. I had an 88 300E that cost the price of two Camry's to own and maintain. Maintenance alone was worth the price of a new Camry at the time and you could have bought two, put one up on blocks and ran the first one with little maintenance for the life of a VW.
In this year of CC, GTI, and such with the 2.0T was pretty common knowledge that the timing chain tensioners can fail. I think VW even had a recall on them. Most likely the timing chain tensioner failed causing this issue. Totally preventable which is sad.
and a common reason timing chain tensioners fail, is lack of oil. People not checking their oil. However in the VW's I think the problem was that it didn't have anything to stop the piston from exiting the housing of the tensioner, so it'd just keep pushing.
@@TougeSolo well we don't know exactly what the problem is with this particular car all I'm saying is that on this era of Volkswagen it was very common have timing chain tensioner failures it was a faulty part and was fixed with a revised part so if the person didn't get the revised part didn't care to get it done or bought the car used in didn't know about this problem then there you go.
This is a problem with direct injection engines where the valves are not washed with fuel. See it all the time here in the UK even though regular oil changes are carried out and the use of 99 RON fuel. Some of the V8 Audis can be horrendous and lose around 30 bhp because of it. Ford eco boost engines also suffer running issues because of it.
Ninja, a couple of things about these engines... A trick for pulling the turbos off these transverse mounted Volkswagens is to get under the car and remove the fore/aft torque bar and use a ratchet strap hooked to something like the hood latch to pull the engine forward a few inches. Plenty of space back there to work when you do that. Working under the car is also a viable angle. Also, take care with the bolts that secure the turbo to the engine because at least one of them is prone to snapping off. Fuel quality doesn't seem to matter much when it comes to carbon deposits on the EA888s, and as far as I can tell neither does the oil change interval. I think what matters most is the kind of driving you do... city driving gunks them up faster than freeway driving. My GTI went 90k miles of mostly freeway driving without issues and I only had them cleaned because the intake manifold was off. My last 30k has mostly been city driving and now my car is stuttering and misfiring under part throttle driving conditions. Also, these cars are very nice to drive, so wanting to keep it on the road makes sense.
@@JohnAbrahamsenI’m afraid that’s not true, to my knowledge no EA888 has come with port injection. Mine certainly doesn’t have it as I like to think I’d have noticed when I pulled the intake manifold to deal with a faulty (stuck open) injector.
No offense, but suggesting that oil change intervals make no difference is one of the most ill-informed things I've ever read in a YT comments feed. If that's actually the case, then you should be able to change the oil every 100k miles without consequences (which is clearly a ridiculous statement). Oil change intervals are there for a reason, and these days manufacturers are optimistic (to put it politely). I'd rather change my oil more often than the book says and spend an extra $50-$70 a year on oil and filters than $5k or more on major repairs because the oil gummed up and led to engine damage.
@@TheKnobCalledTone. I was speaking strictly in terms of carbon deposits on the valves, and when I read that paragraph again it’s pretty obvious. Of course oil change interval matters, just not for the reason stated in this video.
I've watched a VW/Audi mechanic on Twitch for over 6 years work on this model engine many times and the main cause of the deposits on the intake valves is the direct injection. No fuel going over the valves to keep the intake part of the head clean as you would have in a non-DI engine. He does the walnut blast cleaning on these and they always run better afterwards.
My daughter owned a Tiguan. I told her not to get it. Needless to say she said she will never own another VW! And some of my hard earned money went to VW to fix it! I love her. She had to learn the hard way.
Yup if you are getting Audi or VW get one that was manufactured after 2014. Those have the chain system that last for the life of the car supposedly and it has tension sensors. They were sued over a decade ago for the chains failing way before 100k.
@@au123ful yep. that said, there are other serious design failings that can brick the engine all the way into late teen years, not sure which exactly, but all 888 derived engines are not worth buying used as cars ,unless the price is way below e.g. the current US mkt prices for these Vw and audi cars here in USa.
I’m not sure I’d blame that on oil changes, that’s one of the cleanest looking engines I’ve seen under a valve cover. On the valve stems themselves it was disgusting, but that’s what to expect with some VW DI engines. IMO.
VWG 2.0Ts are to be written off and never fixed…..after 60k miles they are not worth any major repairs that arise…..trade them… for the 5 and 10k mile oil change crew, I’ve gone over 10k on my 3L TDI…the issue isn’t the frequency, the issue is the build quality of the motor. Even with the best TLC and heck 3k mile oil changes, let’s be honest it’s a garbage engine planned for obsolescence….it will make it to the 3 year warranty and go tits up no matter what you do.
I wouldn't say that engine has had a lack of oil changes? All components look pretty clean and free from sludge apart from the direct injection carbon build up on the valves.
I've always told myself that with every turbocharged car I've ever owned, a 5k mile oil and filter change interval with synthetic is cheap, cheap insurance. I bought a "sludged" 2004 Passat 1.8t wagon back in 2009 for $4500 and after rebuilding the head, doing a timing belt service and replacing the oil pump and cleaning the pan, it was a faithful servant to me for many years.
I bought a 2015 escape with the 2.0 turbo changed oil every 5k with supertec full synthetic and every other fluid changed ahead of time and now my son drives it to school. Still runs good at 235,000ish miles.
Well the 1.8 T is still a MPI type of engine that cleans itself from the carbon buildups. Later direct injection engines all suffer the problem of the carbon buildups that are caused by the fact that modern cars all recirculate the exhaust gases this means a modern car runs up to 70% of the air that's used to fill the cylinders has already been used in a previous combustion. In order to increase the filling rate of the cylinder the hot exhaust gases have to be cooled down and this is done in a combined valve cooler device that's connected to the cooling water cycle. However the cooler gas cannot contain the same amount of smut like the hotter gas and so you create the buildups. This is the mother of the problem the cooler you make the gas the better for the efficiency of the motor but the more carbon buildups you have and it seems the engineers of VW have put too much weight on fuel economy and not so much on durability. Others might have made other decisions. Regular oil changes help and there are also some additives available that shall help to clean the system but I don't know how good they are. Luckily my car doesn't have any of these problems since I am running it on LPG and when I am making an oil change after 10,000 miles the oil is still of a dark honey colour instead of the black you get from petrol or even worse diesel engines. However the LPG conversion is not cheap at first place and I don't know if LPG is available in the US here in Europe it is different for country to country.
Several gas and diesel turbos in the family. From an X1 to a Juke to Macan S to mini Duramax Colorado. The gassers get 10 k km (6 k miles) oil changes except the Macan. It has an 8 litre sump. It goes 15 k km 9 k miles). The diesel is 12 k km. Don’t EVER look at a diesel intake manifold. Looks like asphalt. Oh ya only 87 gas is all of them. Including the Moto Guzzi. Don’t bag drive them to red line and they’ll reward you with several hundred thousand miles like ours.
@@habi0187 Here in the US my dad had a farm tractor converted to propane back in the 70's, today it's not cost efficient compared to petrol. It's a popular fuel for home heating in rural areas.
@@lo1234-w9r here in Europe it's different LPG is about 40% cheaper than petrol or diesel so if you drive enough it pays back. Additionally you can avoid many problems with the engines as long as the system is implemented professionally. Unfortunately there are not many shops that can do it really good.
@@jbphilly1234 Skin is the largest organ, by surface, of the human body. It will absorb to varying degrees ANY fluid that is placed on it. Hydrocarbons/petroleum distillates are not substances that are recommended for human contact. Used hydrocarbons, even more so. Having one's hand soaked in it for hours and hours on end, every day, day after day, is just asking for trouble...Modern day humans are sometimes exposed to dangerous chemicals in situations that cannot easily/cheaply be avoided. Wearing protection gloves is not one of them.
Gas didn’t do that. Ignoring obvious timing chain slap did that. Gas shouldn’t make a difference. If you’re not changing the oil, then the tensioners stop working and the chain can work it’s way loose. Known issue on VAG engines. That said, I’ve run both my TDIs and Hybrid Jetta on the factory oil change schedule. But I was driving 30k miles a year. IMHO the big issue is time between oil changes. The stuff just gums up over time. This is where disuse is worse than running the crap out of an engine
9 months/7k mile oil changes with the correct spec oil are about right. Any earlier and it's overkill but leave it longer and the oil loses the properties required to lubricate and protect the various components adequately
This is from people that believe the 10K OCI on the jug of oil. Ahmed from the Car Care Nut channel showed a Camry that was burning through oil like there's now tomorrow because of it. The customer was rewarded with a new short block.
That was a good episode. And not only mileage on the oil, but some of these odd new oil specs that can "flat spot" [as in fail to maintain a minimum of 8 psi per 1k rpm]. Who cares what meager fractional fuel economy "gain" is when it makes the engine fail prematurely? I respect design for cold viscosity - they want 0w, then ok. Flow is worth more than pressure at start up. But that is not where an engine lives: 30 [hot] seems to make the most sense, except for the tightest of engines. I will definitely never trust 16 except I need to run in Antarctic or the nether regions of Canada midwinter.
I really enjoy your channel. Hope you make videos for a long time. I am pretty good do it yourself mechanic and enjoy this content. Thanks for sharing.
I like Johnny, but how does cheap gas = carbon on a DI motor? Since fuel never hits the valves, it makes 0.0 difference on carbon buildup. Next, oil changes. Does clean oil burn off valves better? Deposits on the valves are the direct result of a poor performing PCV system; sometimes from lack of maintenance, and many times from simply poor design. Oil hitting the valves + no fuel to wash it off like a port injection motor = this.
its designed that way so this repair eventually happens to all GDI's , its called planned obsolescence . So essentially, Greta grenaded this guys engine .
I'm no mechanic, but if the oil change interval was too long wouldn't we also have expected to see some varnishing on the heads? Or is that only old oil and doesn't happen with fully synthetic?
I think lack of oil changes allows excessive carbon build up in the oil. This jams the oil control rings starting a cycle of oil burning and carbon build up. Detergent in the gas helps keep the rings free a little bit also less EGR necessary with the right octane. All these modern engines are a bit sensitive with small clearances and passages.
In Europe walnut blasting the intakes is standard maintenance. Oil changes and the correct fuel prevent exessive carbon jamming the oil control rings.@@5thelementcannabisproduction
These are just terrible engines. Ours 2010 CC had the timing chain tensioner fail with only 72k km (45k miles) on the odo, oil was changed every 12k km (7.500 miles).
Cheap gas ? Exactly, how is that determined? Who sells this and where? Hint.... there is not. There is contaminated fuel, but "cheap gas" is BS mechanic double talk. Christ, he's never worked on a transverse powertrain? Where you been the last 50 years?
Thanks for another informative video, Ninja. Just crazy to see all those bent valves. It makes me very glad I have been changing LiquiMoly 5W-40 out of my 2013 328i every 5K miles. I also use only Shell 93 octane fuel. At 149K miles, my timing chain is still quiet.
I guess everyone should know, that “Volks-“ of Volkswagen in German means average or cheap😂. The cars are not cheap, but the quality. They are made to fail. Like Audi. There is a big difference to Bmw and Mercedes.
LOL the expressions on your face was worth watching as you progressed through the horror of it all. Thinking if only they serviced this car properly! My wife drives a 2020 Toyota Camry SE and we just had the coolant and transmission serviced at 45k miles and the service tech at Toyota says they recommend transmission service at 80k miles and I was yeah they do because they want to sell me a new transmission at some point. For years I have always serviced my transmissions every 45k and never had problems and always got 200k or more out of them. I have a cousin who purchased a Nissan Maxima with a CVT and I told him service it every 25-30k and he did and he now has 220k on a Nissan CVT!
would note if you think cheap gas saves you money, go see how many miles you can go on a tank on cheap gas vs quality gas, the difference might surprise you and actually make the quality gas the cheaper option.
This happened on my 2014 Jetta GLI at 105K Miles. All scheduled maintenance was done early and premium top tier gas was always used. It's just a bad design and is a common problem on this motor. VW lost a class action lawsuit regarding timing chain failure on this motor. Also, You will see carbon build up on the intake valves of Direct Injection Motors no matter what kind of fuel you use,. As the fuel never touches the back of the valves like a Port Injected Motor.
I enjoy Jonny's video's too but I think if he had a choice he wouldn't be doing them. I just get the feeling that being in front of the camera isn't his thing.
failed from known bad tensionner on these engine. The carbon is normal for a volks direct injection thats never been cleaned. Oil and gas has nothing to do with this failure, the tensionner is the culprit. Just a terrible choice in the engineering department, since you know, weve only been making cars for 200 years
Yes, considering he doesn't know what he's doing and is just winging it without following the factory procedures. Also, disappointed in how it looks like he plans to repair the head -- by just plopping in new valves. This car should have a rebuilt head, and new tensioners, chains, cam bridge, possible turbo, etc.. This is a hack repair. Not impressed.
I had the CC after this generation purchased new and it depreciated like a rocket powered stone thrown off a cliff. I haven't looked at Gen 1 CC values on pre-owned market but this looks like a pretty big investment. That CC must have some sentimenal value to the owner. 😮
That isn't what caused the timing chain to jump. When oil changes are too infrequent it causes the timing chain to wear and "stretch". This causes loss of tension, and that loss of tension on the timing chain is what allows it to "jump" teeth. The cheap gas doesn't have some of the detergents better gasoline has which helps cut down on carbon deposits and other contaminants inside the engine. Combine that with infrequent oil changes and you're just circulating a lot of extra abrasive material inside the engine, wearing critical parts sooner.
@@costasmandylor7252 lol, how does a lack of detergent in the fuel help carbon buildup on a direct injection engine, where the valves never see ANY fuel. Talk about some bad info.
Oil circulates throughout the engine. And there are more wear points in the engine than just the valves. Re-read the original question. What doesn't get burned off in combustion ends up in the oil. The more contaminants in the oil, the more abrasives grinding on the working parts of the engine. Better gas burns cleaner and the better additive package reduces the particulate contaminants in the engine that then ends up circulating around in the oil. Better gas and better OCI's = less timing chain stretch, which keeps it from jumping teeth and bending your valves.
The issue on the 09-12 Passat and CC is the shitty camchain tensioner. There was a class action lawsuit over it, and VW revised the design at least three times.
@@jondiaz3475 Unfortunately tensioners going bad is pretty common. Some manufacturers make it easy to replace them, like Honda on their K series engines.
I agree. I have burned nothing but regular for 15 years in my Toyota’s and Lexus’s and no carbon issues at all. Computers can compensate for lesser fuel. If a car is having carbon issues it’s die to the fact that the engine was designed properly and gas and oil changes can only do so much. At the end of the day, folks…if you want reliability and durability I would not be buying anything from Germany.
@@jbphilly1234 My wife’s lx570 calls for premium, guess what, we run it on regular and it runs great. It’s a 100k vehicle and I don’t lose any sleep that regular fuel is detrimental. The computer, again if designed correctly, compensates. Instead of having 381hp it puts out 376hp according to a Toyota engineer I have spoken with.
@@maxheadroom224 Even the Toyota’s and Lexus’s that use direct injection run just fine with regular gas, because why,,.they know how to engineer them correctly. Oh and they use port and direct injection together so they don’t have the carbon issues in the first place. BMW and Mercedes, please stop your insanity. We all know you make crap cars and most people lease them and then the poor guy who doesn’t know better buys it used and thinks he’s getting a great deal. Look I just bought a 70k bmw for 25k, then over the next year he spends 10k in repairs, and repeat every year after until someone like Hoovie comes along and buys it 10 years old for peanuts to make a video to pay for all of the repairs while caught on camera to make us all laugh.
@@jbphilly1234 High octane fuel is only necessary to achieve the power rating advertised by the manufacturer. Otherwise, the PCM is listening for knock all the time and will just pull timing if it is detected and you make less power. That's it, that's all. The low octane/high octane thing is a myth that just will not die... it has not been a thing since the advent of EFI.
I changed my oil and oil filter at my dealer garage last week and mechanic said I will ruin engine with regular changes every 5k milage. Went to a independent from dealer who said doing what Im doing will take car to a million miles on clock....whose correct im confused?
Change oil once a year, even if you put less than 5k miles on it. Change at 5k at the max with manual demanded oil. Ignore that 10k mile nonsense. Also, don't ignore your trans fluid. "Lifetime" means you're going to rebuild that bugger, or replace it, at some point. They have filters for a reason. Also, don't neglect radiator flushes and plugs/wires or coils. Maintenance can be expensive, but nowhere near the cost of a new engine and/or transmission.
Regular oil changes are necessary, change the oil more frequently then what is stated in the owners manual. Gasoline is Gasoline, just follow the owners manual as to what octane the vehicle requires
I would have stopped once I saw the sludge and bent valves. Called up the customer, and quoted a new engine. Even if this one is repaired, it’s still going to open a can of worms for problems in the future.
I owned a 2012 GTI 6spd 2.0 from new. Change the oil every 4-5K with Castro 5W-40 Euro and OE VW Oil filters. At 60K- Boom! Bent valves and carbon up the wazzooo Oh... by the way, I strictly put BP/Amoco Ultimate or Shell 93. Loved the car, but never a VW again! Never! Just a little thing called a faulty timing chain tensioner... bad design. VW is on their 40th rendition I believe. And chunks of carbon like you wouldn't believe!
Hi Jonny. You would have been a great orthopedic surgeon. Maybe you will change the name of your UA-cam channel from Car Ninja to Car Surgeon. I love watching you work.
This is why Americans should generally not buy Euros... not because of they're awful or anything... it's because most Americans aren't fastidious with upkeep and maintenance on their autos. Most of you reading this who do care are in a very distinct minority.
A rule of thumb that I have found helpful. -Non-high performing vehicles (Camry, Corolla, Altima, etc, change oil every 7k-7.5k miles (if using full synthetic. -High performing vehicles (mustangs, Lexus, Challengers, Chargers, Camaro, etc, change oil every 5k-6k miles. Also, intervals will change depending on how your drive, driving conditions in your area, idling time, quality of oil, average temperature of oil (high temperature can break down detergents in oil more quickly), and quality of oil filter. There are other things as well. Keep your car healthy y’all!🫡
I change my oils every year, including transmission oil 🤔Dunno if its overkill but its a volvo with aisin automatic, not most reliable autos and im at 333whp, and alot of people said they can handle around 300whp 😔
Those 2.0t motors are money pits. 5k oil change intervals, lots of preventative maintenance and top tier fuel will keep them alive. Honestly the v6/vr6 engines are better and way more reliable.
I may understand the oil (direct injection + old oil = carbon) but what the fuel has to do with carbon deposit on valves, considering it's injected straight into the combustion chamber?
$50 oil change vs $5,000 engine repair. I would rather change the oil myself, even if it’s on a car that’s a pain in the a$$ to work on. I always change mine every 5k miles, and my transmission fluid I change every 30k miles.
Myself I would not match the parts. Let them equalize. Good oil will take care of abnormalities. From Aurora Illinois. Thanks for the vids. Saw you on Jr's vids
I have a Camaro SS1le, bought it new and had the first oil change at 800 miles. After that I change my oil and filter every 2,000 miles. Overkill? Yes, but this is just me. I drive it hard so I take extra care.
Your not American ,,you should know better,,,,It's not a 2.0 it's pronounced 2 litre ,,,,,that's it,,,,,,,not 2.0 litre .....you wouldn't go in a shop in America and ask for a 2.0 quarts of milk would you,,,,well in Europe we say 1 litre or 2 litre or 2.2 litre or 3 litre ect....
Johnny / YT. how does everyone feel about the 3rd GEN TSI. I have a 2017 Passat with the 1.8t. Not to be confused with the almighty mk4 1.8t. I've been doing 5k oil changes and just hit 50k. anything to look out for / preventative maintenance I should look for
WHY do people buy nice cars and then drive them into the ground …. And then complain about them….. I JUST DON’T GET IT 😱😱😱 i will put $5.00 on the fact that the owner will come back and complain about the fact that you ruined the turbo while working on it!😜
DI is the root problem. No DI, DPF, EGR, SCR or swirl-flaps on my car. I my happy use a bit extra fuel to keep the car running well; I'm not chasing higher MPGs but look at the total cost of ownership. Once the car is warm is I use the revs, keeping the oil pressures up for better turbo life. Cool the car down. I always service including the ATF and sump none of this lifetime servicing and when things get worn out I build back better...
The newer the car... the more complicated;the more likely to develop a breakdown AND the more expensive the repair!! Keep in mind that,as fueldriven cars will become extinct,the reputation of the combustion engine has no importance at all..... in fact the more sick and tired carowners become of petrol (and Diesel-) cars the smoother the introduction of electric vehicles will be... Wake up to the fact that reliable (more expensive-) combustion-engines is probably counter-effective to almost every carproducer!!!! I have returned to old cars (from ‘28 Model A up to ‘70’s Citroen)..... so much fun to drive,and if one car has a problem there is always another one ready to go.... I can fix everything myself,parts are cheap.... no depreciation,no roadtax.... cheap insurance.... and everybody loves classic cars!!!
The dealership thinks I am crazy for doing 5k oil changes on the wifes Audi. Oil is cheap and recyclable....and it saves you from all of this.
Smart man
Makes me apprehensive to buy a used car in case the owner followed those ridiculous manufacturer oil change intervals. They don’t care about your car as long as it makes it out of the warranty period!😔
The BMW dealer thought I was crazy for not following the 15k mile rule on my 335i. Never would I run a $20k engine that long on oil that costs $60 to change.
@@slscamggood man my 335 just spun a rod bearing 5 thousand kilometres after buying it im assuming since the previous owner did not keep a proper oil change interval on n54 super sad ngl
My Toyota dealer thinks I'm crazy too for changing oil 🛢 at 5k....they recommend 10k but I'm doing every 5k.
You can change the oil every day and fill with the most expensive fuel, but that will not save you from the carbon deposits that are the result of direct injection
This is why I do a fuel system service every 5k along with synthetic oil and 87 octane per owner's manual on my 2021 Hyundai Sonata Limited 1.6 T.
Other maintenance items would include tire rotate and balance. 4-wheel alignment every 2 5k oil services.
@@jeffreycheng5984 fuel system service has no impact on direct injection, except maybe keeping combustion chambers cleaner. Valve are not touched by gasoline - extended oil change intervals CAN impact them due to oil vaporization/evaporation.
Why is Toyota the only automaker to use both direct and indirect fuel injection?
@@KM-ol5bs thanks, I didn't know
@@KM-ol5bs Ford uses on the Coyote (5.0)- the port injection is only used under high load, intake ports still get nasty- a 100k Coyote has valves and ports like a 40-50k DI engine. Good Oil is key. Not quick lube/Walmart cheap oil changes!! (Those ever, not just DI). QUALITY synthetic oils changed 5-7k will drastically reduce the garbage in the intake and ports/valve... Drastic as 25-40% improvement...
Oil catch cans DO help... Again QUALITY IS KEY... Cheapest on Amazon/eBay is not going to do the trick....
Pretty common to have carbon buildup like that on a direct injection, regardless of the grade of fuel used or oil change interval.
some cars suffer less due to effective PCV system. I've heard that N55 BMW engine is ok , while Audi 4.2 S5 V8 (2007-2010) requires regular blasting.
Exactly what I was thinking. I'm not sure if the 2.0 was direct injected in 2012 but that build up is completely likely with DI engines.
@@eppyz even with direct injection, still should not get this bad.
@@ayayoutuber VW took out the dual injection that the euro cars have that pretty much eliminated this problem... but its also part of routine maintenance... so as long as you get the valves cleaned every 60,000 miles is not a big deal. Many earlier direct injection systems did this the newer vw's it's not as bad.
Was about to say the same thing. Oil change intervals and quality of has don’t have anything to do with DI carbon buildup. This would have happened even if the oil was changed every 5k and premium gas was used.
The CC is the type of car that will absolutely punish you for giving it anything less than premium fuel & synthetic oil every 5k miles at the most. The problem is that the older ones can be picked up for about $4k now and the people that do are going to treat them accordingly
@nomenclature9607 haha I was about to add in my original comment that with a Camry you can get away with using low grade gas and being stingy on oil but never a turbo VW
@nomenclature9607 Not everyone wants a Toyota Camry and the owner of this vehicle could have avoided the repairs if they followed the manufacturer's maintenance and fuel requirement recommendations.
Since it is direct injected, fuel does not have any effect at the inlet valves. An oil catchcan can reduce the carbon build up
@@Rextraordinaire German engineering is overly complicated and not too robust. I had an 88 300E that cost the price of two Camry's to own and maintain. Maintenance alone was worth the price of a new Camry at the time and you could have bought two, put one up on blocks and ran the first one with little maintenance for the life of a VW.
in europe they have 18000 miles oil intervals and 2 years.
Great vid thanks Ninja! My naturally aspirated V8 Audi S4 is still running great at 220k kms. I take a larger non turbo engine every time.
In this year of CC, GTI, and such with the 2.0T was pretty common knowledge that the timing chain tensioners can fail. I think VW even had a recall on them. Most likely the timing chain tensioner failed causing this issue. Totally preventable which is sad.
and a common reason timing chain tensioners fail, is lack of oil. People not checking their oil. However in the VW's I think the problem was that it didn't have anything to stop the piston from exiting the housing of the tensioner, so it'd just keep pushing.
@@TougeSolo well we don't know exactly what the problem is with this particular car all I'm saying is that on this era of Volkswagen it was very common have timing chain tensioner failures it was a faulty part and was fixed with a revised part so if the person didn't get the revised part didn't care to get it done or bought the car used in didn't know about this problem then there you go.
Motor looks very clean from an oil change perspective, zero sludge.
This is a problem with direct injection engines where the valves are not washed with fuel. See it all the time here in the UK even though regular oil changes are carried out and the use of 99 RON fuel. Some of the V8 Audis can be horrendous and lose around 30 bhp because of it. Ford eco boost engines also suffer running issues because of it.
Ninja, a couple of things about these engines...
A trick for pulling the turbos off these transverse mounted Volkswagens is to get under the car and remove the fore/aft torque bar and use a ratchet strap hooked to something like the hood latch to pull the engine forward a few inches. Plenty of space back there to work when you do that. Working under the car is also a viable angle. Also, take care with the bolts that secure the turbo to the engine because at least one of them is prone to snapping off.
Fuel quality doesn't seem to matter much when it comes to carbon deposits on the EA888s, and as far as I can tell neither does the oil change interval. I think what matters most is the kind of driving you do... city driving gunks them up faster than freeway driving. My GTI went 90k miles of mostly freeway driving without issues and I only had them cleaned because the intake manifold was off. My last 30k has mostly been city driving and now my car is stuttering and misfiring under part throttle driving conditions.
Also, these cars are very nice to drive, so wanting to keep it on the road makes sense.
EA888 have dual injectors (intake and direct). Deposits shouldnt be a problem.
@@JohnAbrahamsenI’m afraid that’s not true, to my knowledge no EA888 has come with port injection. Mine certainly doesn’t have it as I like to think I’d have noticed when I pulled the intake manifold to deal with a faulty (stuck open) injector.
No offense, but suggesting that oil change intervals make no difference is one of the most ill-informed things I've ever read in a YT comments feed. If that's actually the case, then you should be able to change the oil every 100k miles without consequences (which is clearly a ridiculous statement).
Oil change intervals are there for a reason, and these days manufacturers are optimistic (to put it politely). I'd rather change my oil more often than the book says and spend an extra $50-$70 a year on oil and filters than $5k or more on major repairs because the oil gummed up and led to engine damage.
@@TheKnobCalledTone. I was speaking strictly in terms of carbon deposits on the valves, and when I read that paragraph again it’s pretty obvious. Of course oil change interval matters, just not for the reason stated in this video.
ninja clown
You're looking tired there Buddy. All the best to you and the team.
I've watched a VW/Audi mechanic on Twitch for over 6 years work on this model engine many times and the main cause of the deposits on the intake valves is the direct injection. No fuel going over the valves to keep the intake part of the head clean as you would have in a non-DI engine. He does the walnut blast cleaning on these and they always run better afterwards.
Intake cleaning ought to be routine maintenance item, but the VAG pretends it doesn't exist.
My daughter owned a Tiguan. I told her not to get it. Needless to say she said she will never own another VW! And some of my hard earned money went to VW to fix it! I love her. She had to learn the hard way.
People never learn from begging
I know your pain I spent 8k in repairs in a 2012 VW in 6 month time period. I fix one thing then 2 weeks later there is another problem
Total garbage cars
german SUV's are on another realm of expensive
That was the infamous VAG 2.0 TSI engine chain tensioner fail. It would've happened even if oil was changed every 1000 miles.
Yuppp its made to last "100k" you have to change it or it will fail
Yup if you are getting Audi or VW get one that was manufactured after 2014. Those have the chain system that last for the life of the car supposedly and it has tension sensors. They were sued over a decade ago for the chains failing way before 100k.
Also oil consumption issues are more likely fixed after 2014
@@au123ful yep. that said, there are other serious design failings that can brick the engine all the way into late teen years, not sure which exactly, but all 888 derived engines are not worth buying used as cars ,unless the price is way below e.g. the current US mkt prices for these Vw and audi cars here in USa.
I’m not sure I’d blame that on oil changes, that’s one of the cleanest looking engines I’ve seen under a valve cover. On the valve stems themselves it was disgusting, but that’s what to expect with some VW DI engines. IMO.
VWG 2.0Ts are to be written off and never fixed…..after 60k miles they are not worth any major repairs that arise…..trade them… for the 5 and 10k mile oil change crew, I’ve gone over 10k on my 3L TDI…the issue isn’t the frequency, the issue is the build quality of the motor. Even with the best TLC and heck 3k mile oil changes, let’s be honest it’s a garbage engine planned for obsolescence….it will make it to the 3 year warranty and go tits up no matter what you do.
I wouldn't say that engine has had a lack of oil changes? All components look pretty clean and free from sludge apart from the direct injection carbon build up on the valves.
Its a VW it would have had problems even if you used top tier gas and changed the oil every 3k
I've always told myself that with every turbocharged car I've ever owned, a 5k mile oil and filter change interval with synthetic is cheap, cheap insurance. I bought a "sludged" 2004 Passat 1.8t wagon back in 2009 for $4500 and after rebuilding the head, doing a timing belt service and replacing the oil pump and cleaning the pan, it was a faithful servant to me for many years.
I bought a 2015 escape with the 2.0 turbo changed oil every 5k with supertec full synthetic and every other fluid changed ahead of time and now my son drives it to school. Still runs good at 235,000ish miles.
Well the 1.8 T is still a MPI type of engine that cleans itself from the carbon buildups. Later direct injection engines all suffer the problem of the carbon buildups that are caused by the fact that modern cars all recirculate the exhaust gases this means a modern car runs up to 70% of the air that's used to fill the cylinders has already been used in a previous combustion. In order to increase the filling rate of the cylinder the hot exhaust gases have to be cooled down and this is done in a combined valve cooler device that's connected to the cooling water cycle. However the cooler gas cannot contain the same amount of smut like the hotter gas and so you create the buildups. This is the mother of the problem the cooler you make the gas the better for the efficiency of the motor but the more carbon buildups you have and it seems the engineers of VW have put too much weight on fuel economy and not so much on durability. Others might have made other decisions. Regular oil changes help and there are also some additives available that shall help to clean the system but I don't know how good they are.
Luckily my car doesn't have any of these problems since I am running it on LPG and when I am making an oil change after 10,000 miles the oil is still of a dark honey colour instead of the black you get from petrol or even worse diesel engines.
However the LPG conversion is not cheap at first place and I don't know if LPG is available in the US here in Europe it is different for country to country.
Several gas and diesel turbos in the family. From an X1 to a Juke to Macan S to mini Duramax Colorado.
The gassers get 10 k km (6 k miles) oil changes except the Macan. It has an 8 litre sump. It goes 15 k km 9 k miles). The diesel is 12 k km.
Don’t EVER look at a diesel intake manifold. Looks like asphalt.
Oh ya only 87 gas is all of them. Including the Moto Guzzi.
Don’t bag drive them to red line and they’ll reward you with several hundred thousand miles like ours.
@@habi0187 Here in the US my dad had a farm tractor converted to propane back in the 70's, today it's not cost efficient compared to petrol. It's a popular fuel for home heating in rural areas.
@@lo1234-w9r here in Europe it's different LPG is about 40% cheaper than petrol or diesel so if you drive enough it pays back. Additionally you can avoid many problems with the engines as long as the system is implemented professionally. Unfortunately there are not many shops that can do it really good.
Why do German manufacturers produce such shitty engines? rhetorical question 😁 Great job Ninja!
Can't believe it didn't damage a piston, owner got lucky with that one.
Jonny, would love to see longer videos of your work, it’s educational and entertaining 👍
I am selfish...I want to see CarNinja videos for the next 30 years: Car Ninja, please, please, please...make sure to always wear gloves.
??????
Because engine oil is carcinogenic. Wear gloves and wash your hands regularly
@@jbphilly1234 Skin is the largest organ, by surface, of the human body. It will absorb to varying degrees ANY fluid that is placed on it. Hydrocarbons/petroleum distillates are not substances that are recommended for human contact. Used hydrocarbons, even more so. Having one's hand soaked in it for hours and hours on end, every day, day after day, is just asking for trouble...Modern day humans are sometimes exposed to dangerous chemicals in situations that cannot easily/cheaply be avoided. Wearing protection gloves is not one of them.
Gas didn’t do that. Ignoring obvious timing chain slap did that.
Gas shouldn’t make a difference. If you’re not changing the oil, then the tensioners stop working and the chain can work it’s way loose.
Known issue on VAG engines. That said, I’ve run both my TDIs and Hybrid Jetta on the factory oil change schedule. But I was driving 30k miles a year. IMHO the big issue is time between oil changes. The stuff just gums up over time. This is where disuse is worse than running the crap out of an engine
9 months/7k mile oil changes with the correct spec oil are about right. Any earlier and it's overkill but leave it longer and the oil loses the properties required to lubricate and protect the various components adequately
This is from people that believe the 10K OCI on the jug of oil. Ahmed from the Car Care Nut channel showed a Camry that was burning through oil like there's now tomorrow because of it. The customer was rewarded with a new short block.
That was a good episode. And not only mileage on the oil, but some of these odd new oil specs that can "flat spot" [as in fail to maintain a minimum of 8 psi per 1k rpm]. Who cares what meager fractional fuel economy "gain" is when it makes the engine fail prematurely? I respect design for cold viscosity - they want 0w, then ok. Flow is worth more than pressure at start up. But that is not where an engine lives: 30 [hot] seems to make the most sense, except for the tightest of engines. I will definitely never trust 16 except I need to run in Antarctic or the nether regions of Canada midwinter.
I still don’t understand how cheap gas and gunky oil made those bent valves. It take a huge force to bend valve stems like hitting the cylinder.
Proper lube makes everything run smoother, if not it makes the engine work hard cause of the pressure
It is amazing how calm you remain with all the crap that comes your way. Great job Ninja!!
Gotta have patience to work on a BMW. He called it before he took it apart 👍
he gets paid regardless. it's not like he's doing this for free.
@@sihotechyes but he gets paid based on scale. The longer he takes the less he makes.
All because people listen to the dealership which says 15k intervals for oil change. People who are informed and smart change the oil every 5000
I really enjoy your channel. Hope you make videos for a long time. I am pretty good do it yourself mechanic and enjoy this content. Thanks for sharing.
I just watched a video where Jonny complained about working on a 2010 Volvo S80 3.2. Any transverse mounted engines are a major pain to work on
I like Johnny, but how does cheap gas = carbon on a DI motor? Since fuel never hits the valves, it makes 0.0 difference on carbon buildup.
Next, oil changes. Does clean oil burn off valves better? Deposits on the valves are the direct result of a poor performing PCV system; sometimes from lack of maintenance, and many times from simply poor design. Oil hitting the valves + no fuel to wash it off like a port injection motor = this.
its designed that way so this repair eventually happens to all GDI's , its called planned obsolescence . So essentially, Greta grenaded this guys engine .
True, Euro spec gets both GDI and Port injectors. The reason VW does not do the same here is US is not as strict as Euro 5 requirements. Absolute BS .
I'm no mechanic, but if the oil change interval was too long wouldn't we also have expected to see some varnishing on the heads? Or is that only old oil and doesn't happen with fully synthetic?
I think lack of oil changes allows excessive carbon build up in the oil. This jams the oil control rings starting a cycle of oil burning and carbon build up. Detergent in the gas helps keep the rings free a little bit also less EGR necessary with the right octane. All these modern engines are a bit sensitive with small clearances and passages.
In Europe walnut blasting the intakes is standard maintenance. Oil changes and the correct fuel prevent exessive carbon jamming the oil control rings.@@5thelementcannabisproduction
These are just terrible engines. Ours 2010 CC had the timing chain tensioner fail with only 72k km (45k miles) on the odo, oil was changed every 12k km (7.500 miles).
Lack of maintenance is what keeps the repair shops in business. At least change the oil people! Good stuff, thanks
Cheap gas ?
Exactly, how is that determined? Who sells this and where?
Hint.... there is not. There is contaminated fuel, but "cheap gas" is BS mechanic double talk.
Christ, he's never worked on a transverse powertrain?
Where you been the last 50 years?
Thanks for another informative video, Ninja. Just crazy to see all those bent valves. It makes me very glad I have been changing LiquiMoly 5W-40 out of my 2013 328i every 5K miles. I also use only Shell 93 octane fuel. At 149K miles, my timing chain is still quiet.
N52 is prettily much indestructible. Mine is a 2011 and a little over 75k so it’s got a long life ahead lol
Liqui Moly is good oil.
@@DannyGrc My 2013 has the N20. I wish they kept the inline 6 goodness of the N52 for the F30.
@@ginog5037 the car jumped timing. It is an interference engine, so the valves were bent from hitting the pistons.
@@ginog5037
good luck getting any compression out of that engine. Good lucking even turning it over 🙄
I guess everyone should know, that “Volks-“ of Volkswagen in German means average or cheap😂. The cars are not cheap, but the quality. They are made to fail. Like Audi. There is a big difference to Bmw and Mercedes.
It would be interesting to know why it jumped timing, but the carbon on the valves has nothing to do with fuel quality in a direct injection engine.
LOL the expressions on your face was worth watching as you progressed through the horror of it all. Thinking if only they serviced this car properly! My wife drives a 2020 Toyota Camry SE and we just had the coolant and transmission serviced at 45k miles and the service tech at Toyota says they recommend transmission service at 80k miles and I was yeah they do because they want to sell me a new transmission at some point. For years I have always serviced my transmissions every 45k and never had problems and always got 200k or more out of them. I have a cousin who purchased a Nissan Maxima with a CVT and I told him service it every 25-30k and he did and he now has 220k on a Nissan CVT!
would note if you think cheap gas saves you money, go see how many miles you can go on a tank on cheap gas vs quality gas, the difference might surprise you and actually make the quality gas the cheaper option.
My car doesn't even run right on the cheap gas 🤔
It’s cheaper in the long run
This happened on my 2014 Jetta GLI at 105K Miles. All scheduled maintenance was done early and premium top tier gas was always used. It's just a bad design and is a common problem on this motor. VW lost a class action lawsuit regarding timing chain failure on this motor. Also, You will see carbon build up on the intake valves of Direct Injection Motors no matter what kind of fuel you use,. As the fuel never touches the back of the valves like a Port Injected Motor.
We need more videos, Johnny!
I enjoy Jonny's video's too but I think if he had a choice he wouldn't be doing them. I just get the feeling that being in front of the camera isn't his thing.
@@jp-nq5wd Agree- that's probably why there were no new ones for three months.
failed from known bad tensionner on these engine. The carbon is normal for a volks direct injection thats never been cleaned. Oil and gas has nothing to do with this failure, the tensionner is the culprit. Just a terrible choice in the engineering department, since you know, weve only been making cars for 200 years
That engine looked clean inside unless I missed something.
The cars are built to be,cared for not neglected
Amazing how chill and relaxed Car Ninja is considering what he works on.
he has 4 yachts, 3 model girlfriends, 2 lambos, 3 houses, etc. Thats why he is chill.
Yes, considering he doesn't know what he's doing and is just winging it without following the factory procedures. Also, disappointed in how it looks like he plans to repair the head -- by just plopping in new valves. This car should have a rebuilt head, and new tensioners, chains, cam bridge, possible turbo, etc.. This is a hack repair. Not impressed.
@johns6331 The question is the customer willing to pay for the job??
That's funny he probably has a dollar or two@@sniggitty
If you can't afford to look after a car don't have one
I had the CC after this generation purchased new and it depreciated like a rocket powered stone thrown off a cliff. I haven't looked at Gen 1 CC values on pre-owned market but this looks like a pretty big investment. That CC must have some sentimenal value to the owner. 😮
They tanked so fast. I bought a '15 that the original owner paid $41k for. I paid $13.5 in 2019
Want to know bad resale value? Buy a Hyundai 🙄 what a freaking horror show
I change my oil on all my cars that i use every 3 to 4 months.neber had problems with my engines 👍🏽just the way i roll
Could someone please explain exactly how and why low octane gas can cause the timing chain to jump?
That isn't what caused the timing chain to jump. When oil changes are too infrequent it causes the timing chain to wear and "stretch". This causes loss of tension, and that loss of tension on the timing chain is what allows it to "jump" teeth. The cheap gas doesn't have some of the detergents better gasoline has which helps cut down on carbon deposits and other contaminants inside the engine. Combine that with infrequent oil changes and you're just circulating a lot of extra abrasive material inside the engine, wearing critical parts sooner.
@@costasmandylor7252 lol, how does a lack of detergent in the fuel help carbon buildup on a direct injection engine, where the valves never see ANY fuel. Talk about some bad info.
Oil circulates throughout the engine. And there are more wear points in the engine than just the valves. Re-read the original question. What doesn't get burned off in combustion ends up in the oil. The more contaminants in the oil, the more abrasives grinding on the working parts of the engine. Better gas burns cleaner and the better additive package reduces the particulate contaminants in the engine that then ends up circulating around in the oil. Better gas and better OCI's = less timing chain stretch, which keeps it from jumping teeth and bending your valves.
The issue on the 09-12 Passat and CC is the shitty camchain tensioner. There was a class action lawsuit over it, and VW revised the design at least three times.
@@jondiaz3475 Unfortunately tensioners going bad is pretty common. Some manufacturers make it easy to replace them, like Honda on their K series engines.
Not worth the price of repair. I had a CC for almost 8 years, and before selling it, the oil consumption was getting bad.
The cheap gas thing is a myth, this will happen regardless of how well cared for it is. Only way to combat it is a carbon cleaning.
I agree. I have burned nothing but regular for 15 years in my Toyota’s and Lexus’s and no carbon issues at all. Computers can compensate for lesser fuel. If a car is having carbon issues it’s die to the fact that the engine was designed properly and gas and oil changes can only do so much. At the end of the day, folks…if you want reliability and durability I would not be buying anything from Germany.
@@jbphilly1234 My wife’s lx570 calls for premium, guess what, we run it on regular and it runs great. It’s a 100k vehicle and I don’t lose any sleep that regular fuel is detrimental. The computer, again if designed correctly, compensates. Instead of having 381hp it puts out 376hp according to a Toyota engineer I have spoken with.
@@hokie9910the engine uses port injection not direct injection
@@maxheadroom224 Even the Toyota’s and Lexus’s that use direct injection run just fine with regular gas, because why,,.they know how to engineer them correctly. Oh and they use port and direct injection together so they don’t have the carbon issues in the first place. BMW and Mercedes, please stop your insanity. We all know you make crap cars and most people lease them and then the poor guy who doesn’t know better buys it used and thinks he’s getting a great deal. Look I just bought a 70k bmw for 25k, then over the next year he spends 10k in repairs, and repeat every year after until someone like Hoovie comes along and buys it 10 years old for peanuts to make a video to pay for all of the repairs while caught on camera to make us all laugh.
@@jbphilly1234 High octane fuel is only necessary to achieve the power rating advertised by the manufacturer. Otherwise, the PCM is listening for knock all the time and will just pull timing if it is detected and you make less power. That's it, that's all. The low octane/high octane thing is a myth that just will not die... it has not been a thing since the advent of EFI.
I changed my oil and oil filter at my dealer garage last week and mechanic said I will ruin engine with regular changes every 5k milage.
Went to a independent from dealer who said doing what Im doing will take car to a million miles on clock....whose correct im confused?
Change oil once a year, even if you put less than 5k miles on it. Change at 5k at the max with manual demanded oil. Ignore that 10k mile nonsense. Also, don't ignore your trans fluid. "Lifetime" means you're going to rebuild that bugger, or replace it, at some point. They have filters for a reason. Also, don't neglect radiator flushes and plugs/wires or coils. Maintenance can be expensive, but nowhere near the cost of a new engine and/or transmission.
That doesn’t look too varnished up. Looks relatively well maintained.
Tell me you don’t know what you’re doing, without telling me you don’t know what you’re doing.
The fact that this owner was willing to go ahead and fix this is a pretty good indicator that your shop labor rate is too low.
he seems to be making enough income. some customers just do not care about price
Too cheap to use premium, which is the recommended gas. Put in 87 octane and get a 5000.00 prize.
Regular oil changes are necessary, change the oil more frequently then what is stated in the owners manual.
Gasoline is Gasoline, just follow the owners manual as to what octane the vehicle requires
I'm a firm believer in 3,000 mile oil changes that's why ALL my vehicles have lasted over 250,000 + miles
Nah you can go 6k with modern synthetic oil and changing the filter each time. My 2008 nissan 350z has 250k miles and I’ve done them for 10 years now
No wonder dealers wants you buy another car with 10k mile oil changes on purpose
Title should be: Poor engine design and disposable modern cars = throw away item
I would have stopped once I saw the sludge and bent valves. Called up the customer, and quoted a new engine. Even if this one is repaired, it’s still going to open a can of worms for problems in the future.
Where do you get cheap fuel? Most gas stations no matter what brand get filled by the same tanker truck.
I thought I was crazy for doing 6K mile oil changes on my bmw
don't change oil, use cheap gas... saved a little..now engine go bye bye.
Frequent oil changes. Top tier fuel. And a weekly Italian tune-up.
The carbon buildup is from normal operation. Those are gdi engines.
I owned a 2012 GTI 6spd 2.0 from new. Change the oil every 4-5K with Castro 5W-40 Euro and OE VW Oil filters. At 60K- Boom! Bent valves and carbon up the wazzooo Oh... by the way, I strictly put BP/Amoco Ultimate or Shell 93. Loved the car, but never a VW again! Never! Just a little thing called a faulty timing chain tensioner... bad design. VW is on their 40th rendition I believe. And chunks of carbon like you wouldn't believe!
If you can't afford to buy a proper German car stick to Asian cars. VW 💩
Hi Jonny. You would have been a great orthopedic surgeon. Maybe you will change the name of your UA-cam channel from Car Ninja to Car Surgeon. I love watching you work.
No amount of oil changes or type of oil would have prevented the chain from stretching and the consequential jump in timing.
Repairing a Toyota is like Appendectomy surgery while repairing a BMW is like Heart Transplant surgery!
Yet they lineup to buy the BMW.
Another quality engine from VW Audi 😂
Where’s the cheap fuel, I’ve been looking all over for it
This is why Americans should generally not buy Euros... not because of they're awful or anything... it's because most Americans aren't fastidious with upkeep and maintenance on their autos. Most of you reading this who do care are in a very distinct minority.
A rule of thumb that I have found helpful.
-Non-high performing vehicles (Camry, Corolla, Altima, etc, change oil every 7k-7.5k miles (if using full synthetic.
-High performing vehicles (mustangs, Lexus, Challengers, Chargers, Camaro, etc, change oil every 5k-6k miles.
Also, intervals will change depending on how your drive, driving conditions in your area, idling time, quality of oil, average temperature of oil (high temperature can break down detergents in oil more quickly), and quality of oil filter. There are other things as well. Keep your car healthy y’all!🫡
I change my oils every year, including transmission oil 🤔Dunno if its overkill but its a volvo with aisin automatic, not most reliable autos and im at 333whp, and alot of people said they can handle around 300whp 😔
This looks more like a VW issue with the tensioner that a oil / gas problem. The inside of that engine looked pretty clean.
***people always try using cheap Gas. Some vehicles are designed to ton on 91 octane. Get over it.
I always buy the cheapest gas but if 91 is required, I put in 91. But I also do a techron gas treatment every year on longer trips.
I thought every direct injection engine gets carbon build up. Im sure being cheap 9n oil changes didnt help.
Ive never even thought of buying a vw, Porsche, or audi. Too afraid of the repair bills. What type of car does the mechanic buy?
Its not the cheap oil .its the crap engine vw using.
Those 2.0t motors are money pits. 5k oil change intervals, lots of preventative maintenance and top tier fuel will keep them alive. Honestly the v6/vr6 engines are better and way more reliable.
5k miles is still a lot. I change my oil every 4k km
It always amazes me that people don't change their oil and use cheap gas. Always use premium gas and change synthetic oil every 5,000 miles.
Sure...spend more money on extravagant cars.
3000/4000
Look at all that plastic. Disposable car.
Will it be cheaper just to get a new engine?.
For me its look like timing problem ...
Hey Johnny, how often do the VW VR6’s come through your shop for work? The 3.2 or the 3.6’s. Trying to see how reliable the newer ones are.
I may understand the oil (direct injection + old oil = carbon) but what the fuel has to do with carbon deposit on valves, considering it's injected straight into the combustion chamber?
I think Johnny misspoke when he said “take the Vanos out” on that VW 😆
$50 oil change vs $5,000 engine repair. I would rather change the oil myself, even if it’s on a car that’s a pain in the a$$ to work on. I always change mine every 5k miles, and my transmission fluid I change every 30k miles.
Great video Ninga, always learn something from watching your video posts.
Thank you.
Me too !!! I always learn something from the Ninja.
Myself I would not match the parts. Let them equalize. Good oil will take care of abnormalities. From Aurora Illinois. Thanks for the vids. Saw you on Jr's vids
I have a Camaro SS1le, bought it new and had the first oil change at 800 miles. After that I change my oil and filter every 2,000 miles. Overkill? Yes, but this is just me. I drive it hard so I take extra care.
To quote a famous youtuber..."oil is cheap, engines are expensive"
You can reference Scotty. Its safe.
@@2fast4all 👍👍
Your not American ,,you should know better,,,,It's not a 2.0 it's pronounced 2 litre ,,,,,that's it,,,,,,,not 2.0 litre .....you wouldn't go in a shop in America and ask for a 2.0 quarts of milk would you,,,,well in Europe we say 1 litre or 2 litre or 2.2 litre or 3 litre ect....
Johnny / YT. how does everyone feel about the 3rd GEN TSI. I have a 2017 Passat with the 1.8t. Not to be confused with the almighty mk4 1.8t.
I've been doing 5k oil changes and just hit 50k. anything to look out for / preventative maintenance I should look for
WHY do people buy nice cars and then drive them into the ground …. And then complain about them….. I JUST DON’T GET IT 😱😱😱 i will put $5.00 on the fact that the owner will come back and complain about the fact that you ruined the turbo while working on it!😜
This has nothing to do with premium gas. Possibly an issue of not using Top Tier gas in a GDI engine.
I agree.
And please explain how any type of fuel would have anything to do with carbon buildup on valves on a Direct Injection engine.
Car ninja is smart!!!
We don’t specialize on Lexus Toyota cars ..!!Asain cars
No broken no fixed no money..
Germans cars is a money pit!!
DI is the root problem. No DI, DPF, EGR, SCR or swirl-flaps on my car. I my happy use a bit extra fuel to keep the car running well; I'm not chasing higher MPGs but look at the total cost of ownership. Once the car is warm is I use the revs, keeping the oil pressures up for better turbo life. Cool the car down. I always service including the ATF and sump none of this lifetime servicing and when things get worn out I build back better...
The newer the car... the more complicated;the more likely to develop a breakdown AND the more expensive the repair!!
Keep in mind that,as fueldriven cars will become extinct,the reputation of the combustion engine has no importance at all..... in fact the more sick and tired carowners become of petrol (and Diesel-) cars the smoother the introduction of electric vehicles will be...
Wake up to the fact that reliable (more expensive-) combustion-engines is probably counter-effective to almost every carproducer!!!!
I have returned to old cars (from ‘28 Model A up to ‘70’s Citroen)..... so much fun to drive,and if one car has a problem there is always another one ready to go....
I can fix everything myself,parts are cheap.... no depreciation,no roadtax.... cheap insurance.... and everybody loves classic cars!!!