Great video, You are the only one the show that problem in the web. Everybody believe that noise coming from inside the transmission and replace them. Problem solved. Thank you very much !!!!!!!
Hi, thanks , but the damper damage 95% it is just a consequence engine misfiring , usually the misfiring is a consequence EGR system malfunction , 1 blocked inlet manifold EGR chanel, 2 EGR cooler, 3 EGR valve ,so before you replaced Damper check inlet manifold ;)
@@melissaflores3804 I'm pretty sure you just change it - it's just a mechanical intervention to stress the electice motor when the ICE charges the battery.
Goodnight having a problem with my prius on cold start on mornings i get loud rattling and as i put it in a gear the noise is gone .....it only happens when the battery is low and the engine activates to recharge ...any tips
Thanks for this video. I have been driving my Lexus CT200H with what seems to be this problem for a while. Its driveable, but makes this cogging noise (sometimes more like a slapping noise - steel clanging on steel) frequently at mid range, or on slow acceleration. No noise at idle, or at top end. Also makes this noise/mild shaking at highways speeds on low engine output. There are no engine codes. I've also checked all EGR components. All clean, and the EGR motor is fine. I've cleaned the MAF sensor, checked the plugs and coils, etc. Ran fuel injector cleaner, checked the air filter, etc. The problem is that I cannot observe this fault, because it only happens during driving, and only when the engine is on, and under load. Finally, I noticed that the engine jerks on start-up. I realized that the problem only occurs when there is a torque in the driveline. Since the computer monitors the engine comprehensively, and also monitors the Hybrid transaxle, I figured this damper/clutch component fits the symptoms. It is the one thing not monitored by the computer, and it only acts up when under load, with engine on. I'm going ahead with replacing mine.
Hello Lyndon Than, I have the same issue with my 2014 Lexus CT200h, I wonder if this would be considered a recall, even though it happens past the warranty mileage, I replaced the transmission with an old damper & the issue came up again, I wonder if putting the new updated pn 31270-47070 will avoid the issue from happening again. Hope FixYourRide13 replies to our messages as the parts dept of the local dealership doesn't know what I'm talking about.
Toyota Auris 2013 (has a 2nd gen Prius hybrid drive) and I am getting the same thing, no codes. Toyota have quoted me 3 grand as, what is essentially a clutch change, is done by taking the engine out, not from underneath.
lyndonthan4350 Hi. I am the owner of the CT200H as well and having this problem. I swapped the engine before, so I know that is not the motor or EGR issue. Did the replacement of the damper helped you?
Need to make sure the runners for the EGR path in the intake manifold are cleaned, cylinder #1 runner clogs and can cause issues similar to this. Other things to check are counterfeit spark plugs, and blown head gasket (watch the coolant level super closely).
@@jg4tunecircle969 I'd think that the clutch damper (Called a Drive Plate on the OEM parts pages) is a tuned mass - to work in conjuction with the vibration frequences of the engine - so can't just swap in a different part.
Great Explanation , it saves me, I thought the sound was coming from the engine or either Transmission. I have made video of that sound, would you please guide me how to upload it to your channel?
I want to change the engine for the same car, model year 2015-2016, and my question is: What are the things that need to be focused on when removing the old engine and before putting the other engine in its place?
Can this rattle cause a vibration while car is moving? I have those springs rattling sometimes when battery is drained and car is moving slowly and depressed the accelerator and car start rattling, also when I drive after 30mph I get a lot of vibration? Please suggest
Hi, first u have to check and clean all inlet system, (egr including) check the spark plugs condition, fuel condition, head gasket blow, the rattling efekt always is from other reasons like it self, rattling and vibration = misfiring, trouble some or all cylinder firing. Very welcome into my Facebook site FixYourRide Garage (pictures)
@@palmerdesigngroup4038 yes, it was clogged egr that had caused an engine knocking and these springs to rattle. After cleaned all system properly I have no problems anymore. 👍
I know this video was from three years ago, but I have a related question and would very much appreciate your thoughts. I recently bought a used JDM (Japanese Direct Motor) engine assembly that came with the damper assembly and flywheel sub-assembly. The damper from the much newer JDM engine looks exactly like the new/revised damper you purchased. My old damper (from my 2010 Prius with 289,000 miles) looks like your old damper as well. I cannot get a definitive answer as to whether the JDM new/revised damper is compatible with my older transaxle. Some "sales people" at JDM retailers are saying it's not compatible and they recommend that I use my old one, and others say the opposite. After you installed the new/updated damper, did you have any problems? Thanks.
Hi, I don't have experience with campers JDM and Europe dampers. But I think should be the same parts. If you have both dampers camper and make video for others 🤘
My 2010 prius is making a rattle / vibration noise coming from the front of the car when I letting go of the gas pedal slowly when I’m costing and I press the gas pedal and release it slowly. Could this be the damper.
My Prius 2012 with 140,000 miles on it stopped me on the road. The car engine nolonger starts but it can move or drive on HV battery only. The scan says P3147, P0335 and P0A0F. But later the P3147 stopped showing. I have changed the crankshaft position sensor, its good but I changed it. checked the reluctor plate inside the engine and its in its position and in good shape and I changed the ECU or brainbox. The crankshaft position sensor wire harness is good. Still the car can't start. Before this issue I have been having rattling and knocking sound in the engine at idle or low speed only when the hybrid battery is charging. If it's not charging the rattling noise doesn't come on. No error codes on that. I cleaned egr valve, nozzles, pc valve, inlet manifold, throttle body and changed plugs still the noise didn't stop. I beginning to think the problem is my transaxle. The MG1 motor that starts and charges the HV battery. Remember I said my car only rattles when the car is charging the HV battery on idle or low speed. Now the car cannot start. I am thinking of changing the whole engine including the transaxle. What do you think the issue is? My location is Lagos Nigeria
@@jafarshirzad9861 change your damper clutch. If it stopped you on the road then it’s expensive fix. You have to change the whole engine or the transaxle with the damper clutch. If it stopped you on the road then the transaxle connector to the engine is broken and the transaxle need to be replaced
I have a sound that seems to be from the planetary gear.. my engine has not been open never.. so I would say it can be the clutch/damper... when you put the new damper the sound persists, why? That’s the same sound I get when the engine starts.. it disappears when I accelerate at high speed..
Hi , check the EGR system ,most problem com one from blocked EGR line in inlet manifold, or EGR cooler , or valve itself. The rattling from the damper it is only result of EGR problrm.
2014 Prius with 750,000 km and engine replaced at about 600,000. i had a "chatter" which seemed to be coming from the front left axle area but was diagnosed by one dealer tech as being the exhaust pipe. made little sense to me, so i called and asked if the tech could contact me at his convenience. he told the service rep that he didn't have time. but i was assured the it would not be a problem to continue driving the car. however the noise was getting louder so i took it to the dealer i bought the car from who usually do any work and maintenance on the car. their techs said it was the transmission. given that they did not confirm the first tech's diagnosis (and either repair was going to cost about the same money) i needed to have more than a hunch. after some back and forth and verifying that the second tech was, in fact, hearing the same noise in their diagnosis as i was on the road, they ordered a transmission with low mileage from a salvage yard. but when they took it apart it became apparent it was the damper clutch. I think one spring might have come right out and another spring was disconnected or broken off on one end. the "chatter" would occur at easy acceleration and disappear at idle or under load. Waiting for the call to say its ready. Thanks for the video. I too have an unusual problem with the engine, which resulted in the first engine failing and the second engine is now doing the same thing... which has me concerned for what will happen down the road. i'll upload the video with description and post a link when I have a moment.
Hi, I see the big story , like you can see on the all comment's be low the video most common problem is from EGR system , damper rattling it is only reactions for bad fuel mixtures. But if you can make video with the sound for camper with my experience that I can try help you. In the channel information you found email address.
@@FixYOURride13 great. So how to fix the bad fuel mixture? Cleaning the intake manifold,the egr valve, the pipe between both and the PCV valve? Perhaps the throttle body too..
@@FixYOURride13 Hi thanks for this video, I have a question please ,so to replace the clutch we have to remove all the transmission or we can replace it with no removing the transmission. Thanks advance.
@@mezianeboghni2948 Hi, you have to removed gearbox, I newer replaced it w/o removed engine with gearbox because I'm replaced it with replaced head gasket, be sure the rattling from clutch damper it is not only efekt off misfiring, very often main problem is in egr system or head gasket leaking.
@@FixYOURride13 Hi, I thank you for this response. I am loosing coolant and have a cylinder 2 missfire, the EGR and EGR coolar has been replaced. Im thinking the headgasket is causing the missfire but it only does sometimes. And also make the rattle sound when the engine is turning on during acceleration for 2 seconds and then goes away.
@@JohnnyAnderson1 hi, it's a bad news, so engine out , remove the head, don't forget skim the head and measure short block. After removing the oil sump check oil strainer condition.
No one talks about it on the web!!!!! Thanks
Great video, You are the only one the show that problem in the web. Everybody believe that noise coming from inside the transmission and replace them. Problem solved. Thank you very much !!!!!!!
Hi, thanks , but the damper damage 95% it is just a consequence engine misfiring , usually the misfiring is a consequence EGR system malfunction , 1 blocked inlet manifold EGR chanel, 2 EGR cooler, 3 EGR valve ,so before you replaced Damper check inlet manifold ;)
When you change the clutch damper you have to program anything or just change it ??
@@melissaflores3804 I'm pretty sure you just change it - it's just a mechanical intervention to stress the electice motor when the ICE charges the battery.
Goodnight having a problem with my prius on cold start on mornings i get loud rattling and as i put it in a gear the noise is gone .....it only happens when the battery is low and the engine activates to recharge ...any tips
Feraz Khan same issue battery low rattling at start up and low speeds when battery low... did you find solution?
Egr valve blocked
Its the headgasket! Go to gasket masters channel.
I have also faceing same issue
Did guys resolve problem by cleaning egr
When you change the clutch damper do you have to program anything ? Or just change the part
Hi, only replace it
How much are the torque of the flywheel screw and the clutch
The damper assembly is £1000 plus 10 hours labour if it is a engine-out job.
Thanks for this video. I have been driving my Lexus CT200H with what seems to be this problem for a while. Its driveable, but makes this cogging noise (sometimes more like a slapping noise - steel clanging on steel) frequently at mid range, or on slow acceleration. No noise at idle, or at top end. Also makes this noise/mild shaking at highways speeds on low engine output. There are no engine codes. I've also checked all EGR components. All clean, and the EGR motor is fine. I've cleaned the MAF sensor, checked the plugs and coils, etc. Ran fuel injector cleaner, checked the air filter, etc. The problem is that I cannot observe this fault, because it only happens during driving, and only when the engine is on, and under load. Finally, I noticed that the engine jerks on start-up. I realized that the problem only occurs when there is a torque in the driveline. Since the computer monitors the engine comprehensively, and also monitors the Hybrid transaxle, I figured this damper/clutch component fits the symptoms. It is the one thing not monitored by the computer, and it only acts up when under load, with engine on. I'm going ahead with replacing mine.
Hello Lyndon Than, I have the same issue with my 2014 Lexus CT200h, I wonder if this would be considered a recall, even though it happens past the warranty mileage, I replaced the transmission with an old damper & the issue came up again, I wonder if putting the new updated pn 31270-47070 will avoid the issue from happening again.
Hope FixYourRide13 replies to our messages as the parts dept of the local dealership doesn't know what I'm talking about.
Toyota Auris 2013 (has a 2nd gen Prius hybrid drive) and I am getting the same thing, no codes. Toyota have quoted me 3 grand as, what is essentially a clutch change, is done by taking the engine out, not from underneath.
lyndonthan4350 Hi. I am the owner of the CT200H as well and having this problem. I swapped the engine before, so I know that is not the motor or EGR issue. Did the replacement of the damper helped you?
Need to make sure the runners for the EGR path in the intake manifold are cleaned, cylinder #1 runner clogs and can cause issues similar to this. Other things to check are counterfeit spark plugs, and blown head gasket (watch the coolant level super closely).
@@jg4tunecircle969 I'd think that the clutch damper (Called a Drive Plate on the OEM parts pages) is a tuned mass - to work in conjuction with the vibration frequences of the engine - so can't just swap in a different part.
does anyone know how to align the damper when bolt to the engine is there marks ? 2011 priuse .
Great Explanation , it saves me, I thought the sound was coming from the engine or either Transmission. I have made video of that sound, would you please guide me how to upload it to your channel?
What video can you send to me because I have the same problem
@@gatimeneshtepi I have the same issue.
Send me the video so I can post here on the comments
i cange break pads and even disk plates
Thank you:)
I want to change the engine for the same car, model year 2015-2016, and my question is: What are the things that need to be focused on when removing the old engine and before putting the other engine in its place?
my toyota prius 2012 making a noice from gearbox while driving and goes off when i select neutral gear . where the problem is ???
Hi, Check all comments below video, ancwaer is there.... I hope😉
@@FixYOURride13 Thanks for teply. how much it will cost to fix it ?? how much is part ??
@@veerpalmahal6970 replaced time will be 2 days work, price for parts you can check in your local Toyota Dealer, It was around 600e euro.
Couldn't you show how to remove & replace the damper clutch
This caused caused my engine and Transaxle.
Hi, usually it's just a misfire effect, so firstly check EGR system ,head gasket leak.
@@FixYOURride13 I checked all that. They were fine.
The cause was my damper clutch.
Can this rattle cause a vibration while car is moving? I have those springs rattling sometimes when battery is drained and car is moving slowly and depressed the accelerator and car start rattling, also when I drive after 30mph I get a lot of vibration?
Please suggest
Hi, first u have to check and clean all inlet system, (egr including) check the spark plugs condition, fuel condition, head gasket blow, the rattling efekt always is from other reasons like it self, rattling and vibration = misfiring, trouble some or all cylinder firing.
Very welcome into my Facebook site FixYourRide Garage (pictures)
FixYOURride13 Thanks
did you ever find the solution to your car rattle when battery low
@@palmerdesigngroup4038 yes, it was clogged egr that had caused an engine knocking and these springs to rattle. After cleaned all system properly I have no problems anymore. 👍
Another toyota car use the same part? i live in central america ans its difficult to get prius parts
Helllo.Nev yəs Demper Tayota Prius 20???
Is it automatic or manual
Thank you for the video. What is the mileage on the original damper?
No idea
How long does it take to do the job
I know this video was from three years ago, but I have a related question and would very much appreciate your thoughts. I recently bought a used JDM (Japanese Direct Motor) engine assembly that came with the damper assembly and flywheel sub-assembly. The damper from the much newer JDM engine looks exactly like the new/revised damper you purchased. My old damper (from my 2010 Prius with 289,000 miles) looks like your old damper as well. I cannot get a definitive answer as to whether the JDM new/revised damper is compatible with my older transaxle. Some "sales people" at JDM retailers are saying it's not compatible and they recommend that I use my old one, and others say the opposite. After you installed the new/updated damper, did you have any problems? Thanks.
Hi, I don't have experience with campers JDM and Europe dampers. But I think should be the same parts. If you have both dampers camper and make video for others 🤘
I have the same problem
first check egr all lines, spark plugs conditions, hesd gasget leak
My 2010 prius is making a rattle / vibration noise coming from the front of the car when I letting go of the gas pedal slowly when I’m costing and I press the gas pedal and release it slowly. Could this be the damper.
Hi, no...first check the EGR system: inlet manifold, EGR valve, EGR cooler probably one of it is blocked, typicall sound.🤘
@@FixYOURride13 i will definitely try to clean the egr system and intake manifold
I have also that same problem did you fixed that sound by cleaing egr system
My Prius 2012 with 140,000 miles on it stopped me on the road. The car engine nolonger starts but it can move or drive on HV battery only. The scan says P3147, P0335 and P0A0F. But later the P3147 stopped showing. I have changed the crankshaft position sensor, its good but I changed it. checked the reluctor plate inside the engine and its in its position and in good shape and I changed the ECU or brainbox. The crankshaft position sensor wire harness is good. Still the car can't start.
Before this issue I have been having rattling and knocking sound in the engine at idle or low speed only when the hybrid battery is charging. If it's not charging the rattling noise doesn't come on.
No error codes on that.
I cleaned egr valve, nozzles, pc valve, inlet manifold, throttle body and changed plugs still the noise didn't stop.
I beginning to think the problem is my transaxle. The MG1 motor that starts and charges the HV battery. Remember I said my car only rattles when the car is charging the HV battery on idle or low speed. Now the car cannot start.
I am thinking of changing the whole engine including the transaxle.
What do you think the issue is?
My location is Lagos Nigeria
Did u find any solution to your car my car has the same problem as u explained
@@jafarshirzad9861 yes
@@jafarshirzad9861 change your damper clutch. If it stopped you on the road then it’s expensive fix. You have to change the whole engine or the transaxle with the damper clutch. If it stopped you on the road then the transaxle connector to the engine is broken and the transaxle need to be replaced
Can I swap gen 4 damper into my old gen3?
Hi, have no idea, I never try it 🤔
Unfortunately no. The damper on the gen4 motor is different. It comes with bigger diameter on the spline shaft and comes with 3 springs instead of 4.
I have a sound that seems to be from the planetary gear.. my engine has not been open never.. so I would say it can be the clutch/damper... when you put the new damper the sound persists, why? That’s the same sound I get when the engine starts.. it disappears when I accelerate at high speed..
Hi , check the EGR system ,most problem com one from blocked EGR line in inlet manifold, or EGR cooler , or valve itself. The rattling from the damper it is only result of EGR problrm.
FixYOURride13 how can I send you a video so you can watch the rattle of my engine? Because it’s very strong it makes the whole car vibrate
@@joaquinlion e-mail address you found in channel information :)
What's happened with you about this problem may you changed the car after this period but if you remember please tell, i have the issue nowadays
2014 Prius with 750,000 km and engine replaced at about 600,000. i had a "chatter" which seemed to be coming from the front left axle area but was diagnosed by one dealer tech as being the exhaust pipe. made little sense to me, so i called and asked if the tech could contact me at his convenience. he told the service rep that he didn't have time. but i was assured the it would not be a problem to continue driving the car. however the noise was getting louder so i took it to the dealer i bought the car from who usually do any work and maintenance on the car. their techs said it was the transmission. given that they did not confirm the first tech's diagnosis (and either repair was going to cost about the same money) i needed to have more than a hunch. after some back and forth and verifying that the second tech was, in fact, hearing the same noise in their diagnosis as i was on the road, they ordered a transmission with low mileage from a salvage yard. but when they took it apart it became apparent it was the damper clutch. I think one spring might have come right out and another spring was disconnected or broken off on one end. the "chatter" would occur at easy acceleration and disappear at idle or under load. Waiting for the call to say its ready. Thanks for the video.
I too have an unusual problem with the engine, which resulted in the first engine failing and the second engine is now doing the same thing... which has me concerned for what will happen down the road. i'll upload the video with description and post a link when I have a moment.
Hi, I see the big story , like you can see on the all comment's be low the video most common problem is from EGR system , damper rattling it is only reactions for bad fuel mixtures. But if you can make video with the sound for camper with my experience that I can try help you. In the channel information you found email address.
@@FixYOURride13 I'll need to send you a video of my '08 Prius engine sound. Will look for your email addie.
@@FixYOURride13 great. So how to fix the bad fuel mixture? Cleaning the intake manifold,the egr valve, the pipe between both and the PCV valve? Perhaps the throttle body too..
Where you get the damper clutch part?
Hi, Only Toyota Dealer
@@FixYOURride13 Hi thanks for this video, I have a question please ,so to replace the clutch we have to remove all the transmission or we can replace it with no removing the transmission. Thanks advance.
@@mezianeboghni2948 Hi, you have to removed gearbox, I newer replaced it w/o removed engine with gearbox because I'm replaced it with replaced head gasket, be sure the rattling from clutch damper it is not only efekt off misfiring, very often main problem is in egr system or head gasket leaking.
@@FixYOURride13 Hi, I thank you for this response. I am loosing coolant and have a cylinder 2 missfire, the EGR and EGR coolar has been replaced. Im thinking the headgasket is causing the missfire but it only does sometimes. And also make the rattle sound when the engine is turning on during acceleration for 2 seconds and then goes away.
@@JohnnyAnderson1 hi, it's a bad news, so engine out , remove the head, don't forget skim the head and measure short block. After removing the oil sump check oil strainer condition.
Is it automatic transmission or manual transmission?
Prius has no manual transmission.
What were the symptoms if the bad damper
Hi, big rattling, but be careful... not all time damper rattling is damper guilty sometimes is just an effect of another defect.