Sometimes the deal can be real lol I remember when I got hurt at work and I was loosing everything and I had to sell my quad as the wife’s car was repo’ed it was 2009 and I put my 2007 Honda rancher 420 up for 4500 ! I needed the cash bad and I received hundreds of emails saying my quad must be stolen ! Well one very lucky fella came and got it as I had tears running down my face as he drove away with it ! Sometimes someone’s misery can be your gain 👍 love the vids 👍
At least I know I wasn't the only one going through times like that. Sure felt like I was. They shut my plant down had to sell my boat and quad just to keep food on the table and roof over our heads for a few extra months. Unfortunately alot of us are heading for it again if we keep this current heading.
Sounds like you got a great deal on this machine. Always nice to know that you didn't get screwed over. Hey man, thanks again for your time today. Enjoy the rest of your weekend.
Good to see at least this one cleaned before commencing work! 😁 As you said, that oil even sounded thin when it hit the pan, its the engines blood people, regular oil and filter changes is cheap insurance.
I could be wrong it happens, but I'm pretty sure that's an Outlaw 500. the 525 motor is completely different than that and that is a Predator 500 motor.
i would invest in a sonic cleaner (heated 1 is good)for all these carbs that need attention it will save you lots of cleaning time inside and out and don't forget to pull out the emulsion tube when cleaning the carby it will also free up seized throttle plates shafts and jets ... well done and good find 👍
Awesome! I have an A 2008 Polaris Outlaw 525 IRS Too! It is a great machine, and 52 horsepower stock! I see at 32:46 you check out the rear and find the wheel bearings are shot. They may be shot but also they could be needle bearings. This is because where the A arms connect to the frame and the carrier, it looks like bushings but it is actually needle bearings. I recently found this out and just removed the needles, cleaned the inside and jam-packed it with grease when re assembling. I'd recommend checking into that because mine had the same movement.
@@thomasambers9977 well ok it’s not fully stock but I have 3 an one put out 115 hp on the fully built motor with a small shot of nos.. my outher one is full bolt on that makes 78 an it’s a 98
That is the clutch package plate rod that has grooves in it that has A washer.& Spring on top& bottom that let's the gear throw in & out more. May need adjustments to get full engagement.
It’s smoking bud I would put some rings or a new piston and rings in it These was always good quads The frame come that color It needs some degreaser and good cleaning it would look way better get all that crap off it
Honestly that looks nothing like the outlaw 525 engine! That is the predator 500 engine. And both the IRS suspension outlaw chassis ATV's had the same platform engine.. one had an outlaw 525 while the other IRS outlaw had a predator 500 engine! It's totally possible that is the case here. It looks like the predator 500 engine in the outlaw chassis.
They come with Douglas wheels from the factory they're only the yellow label rims so they're the cheap ones they're not really worth much it's also missing the dual rate springs out of the front there should be too small springs on top of the larger springs
Run some gum out octane booster.& Gum out carb& choke cleaner shaken up in the bottle mixed together. The pour the measured amount for the gallons in your fuel tank.
I got a Honda trx450er that needed a carb clean and that’s all it needed till 1st gear went out the first day I rode it and then the whole transmission 2 months later.
Yeah definitely I only paid $2400 so if the transmission wasn’t blown soon after it would have been perfect. Bonus is now it is completely built for the price of a working stock one.
You can try to push start quads that have reverse in reverse it tends to be easier to do that way. I have an ltz400 and if needed I'm able to start it in reverse.
Just the inspiration I need to finish my 2007 ninja 250 build , get tyres this w/e and I have all the parts just have to spin some spanners get everything on 👍🏼👍🏼👍🏼👍🏼
Ask? I mean, the engine of the 2006 Outlaw 500 is the same engine that comes with the Predator. I mean, why have I searched for parts or spare parts for the Outlaw, but they almost don't appear, more of the Predator appear.
I don't recommend using the transmission type in your regular oil blends in though at all. Now in your 2 cycle oil yes cause it's made similar to that with more additives in the oils.
Wet clutch oil setups will have pretty dark oil… it certainly needed changed but it’s not that out of the ordinary … nice find for the money. That’s a sharp Looking quad
awesome deal, great video! at 31:40 when she flames out on you while its rolling, with some quick thinking you can quickly pop her back in 2nd gear and use your momentum to try restarting the engine. obviously if it stalled due to out of fuel it's not that helpful... but if it stalled from blipping the throttle and flaming out it should fire right back up.
Read up on that trailtech unit.i have one on my xr 650,and they have a ton of features.it also has an internal battery that you need to change about once a year.
Those jump packs are made to jump start engines. Once the engine starts take it off asap. The charging system will ruin them. Not like the normal big jump pack that’s basically just a battery in a box
Definitely with you I had a 500 outlaw. Still a great quad just not the torque monster 525. That woodruff key is gonna be dust banging off that rev limiter smdh
that's what he was talking about with the two bolts on the bottom side of the motor they have a switch in the motor and a wire connects to it to ground it when it's grounded the neutral light is on its common on Hondas and other some other bikes you just cut and ground that wire and the neutral light stays on works great in mud bikes you can start in any gear say your under the water in gear it dies you just fire it right back up assuming it's a honda you should be good to go
When somebody tells you a bike won't run, then you buy it from them cheap and get it running, you should always ride past them and wave...best feeling ever
mine came stock from day I bought new at dealership in those same colors the reason Polaris did the orange frame and shocks is because that's the KTM 525 motor that's in it so the orange was like a tribute to ktm cuz Polaris provided ktm with the rolling chassis back then so ktm could get in the quad game which I also have one of KTM'S qauds from that era also
I had this problem with my old ltz400 battery had a bad cell and it was sucking all the voltage she would pop and bang and die when you were trying to ride it
$15 hundred What a steal 🔥 BOOM 🔥 Dang right as you said that lol Crazy. That's about how my luck goes too bro. Soon as I brag on something it blows up in my face. 😆 Dang that sucks.
I got a question when you pull in the clutch to down shift do you have to let it go and then down shift again or can you pull it in and down shift thow all the gears
The oil is black af...bc u said u smelt gas in the oil...well the gas acted as tho a cleaner and cleaned the engine out so...ya got a nice engine flush lol luckily it didnt spin a bearing or wipe one out and fixed the carb....polaris makes some good equipment....one of these outlaws won the local line mountain 7 miler race 2 years in a row where I live...the irs I'm sure had alot to do with it
Love your videos man but you can't just keep calling every person you buy from a scammer.... Your just got like a 4000 dollar four wheeler for 1500 and dude said all it needed was a carb clean.. I watch the whole video and every few mins it's I hope I'm not getting scammed cuz it happens 🤷🤔 like I get it your right 110% but have some faith man not everyone's like that brother💯🙏 ❤️ keep up the awesome videos tho ☝️ and good job 👋🍻
I love these ktm 525 there bad ass great buy again Joe. You have the patience n knowledge to get it running as it should so let’s see what’s to come for this one 💪🏻
Honestly I watch a ton of ur vids you should creat ur own business and teach classes on how to rebuild shit, maybe charge 20/30 bucks a person I would 100000000 percent pay that to be taught to take carbs apart and shit like that. Dude you rock bro keep it up man
@@JohnDoe-ww2zf I do believe you are wrong. That is a fugi motor, not a ktm. Are you sure you even know the difference? They made 2 different outlaws.....a 500 and a 525, one with the fugi motor and one with the ktm. The engine side cases say polaris, if it was a 525 it would say KTM on the side cases. So before you go calling someone wrong maybe you should know your atvs.
Sometimes the deal can be real lol I remember when I got hurt at work and I was loosing everything and I had to sell my quad as the wife’s car was repo’ed it was 2009 and I put my 2007 Honda rancher 420 up for 4500 ! I needed the cash bad and I received hundreds of emails saying my quad must be stolen ! Well one very lucky fella came and got it as I had tears running down my face as he drove away with it ! Sometimes someone’s misery can be your gain 👍 love the vids 👍
At least I know I wasn't the only one going through times like that. Sure felt like I was. They shut my plant down had to sell my boat and quad just to keep food on the table and roof over our heads for a few extra months. Unfortunately alot of us are heading for it again if we keep this current heading.
Sounds like you got a great deal on this machine. Always nice to know that you didn't get screwed over. Hey man, thanks again for your time today. Enjoy the rest of your weekend.
Good to see at least this one cleaned before commencing work! 😁 As you said, that oil even sounded thin when it hit the pan, its the engines blood people, regular oil and filter changes is cheap insurance.
I could be wrong it happens, but I'm pretty sure that's an Outlaw 500. the 525 motor is completely different than that and that is a Predator 500 motor.
I think that is is a 525 because it has the independent rear suspension
@@jakebbrap9346 Outlaw 500 had IRS also.
Ya your right I was thinking of the Predator not outlaw
100% not a 525
@@drmoretz The Guy had it listed on facebook for $2900 as a 525 Lol wow
i would invest in a sonic cleaner (heated 1 is good)for all these carbs that need attention it will save you lots of cleaning time inside and out and don't forget to pull out the emulsion tube when cleaning the carby it will also free up seized throttle plates shafts and jets ... well done and good find 👍
Awesome! I have an A 2008 Polaris Outlaw 525 IRS Too! It is a great machine, and 52 horsepower stock! I see at 32:46 you check out the rear and find the wheel bearings are shot. They may be shot but also they could be needle bearings. This is because where the A arms connect to the frame and the carrier, it looks like bushings but it is actually needle bearings. I recently found this out and just removed the needles, cleaned the inside and jam-packed it with grease when re assembling. I'd recommend checking into that because mine had the same movement.
Dude my rm 250 makes 75 stock lol
Ok. Cool? What year
@@theyzoomers what rm 250 makes 75 hp stock ?
@@thomasambers9977 well ok it’s not fully stock but I have 3 an one put out 115 hp on the fully built motor with a small shot of nos.. my outher one is full bolt on that makes 78 an it’s a 98
@@outlaw5256 I was looking at a bike like this buddy says it a great quad no problems get there it’s smoking motors knocking it was a phile
I set search alerts for “needs a carb clean” works wonders.
that's a smart idea!
What a power play. Just added that to my existing alerts. What a guy.
wow what a Chad. genius😂
just unlocked a whole bunch of amazing prices with that..
Chrst code up down legt right back trigger
That is the clutch package plate rod that has grooves in it that has A washer.& Spring on top& bottom that let's the gear throw in & out more. May need adjustments to get full engagement.
looks like it's puffing some smoke out the exhaust on the test ride
I thought it was a 2 stroke engine 😂
Nah man it's just the new 4 smoke engine they got out lmao
probably just needs carb adjustment or clean air filter
It’s smoking bud I would put some rings or a new piston and rings in it These was always good quads The frame come that color It needs some degreaser and good cleaning it would look way better get all that crap off it
I use Rotella T4 or T6 in all my wet clutch engines. Works great, JASO certified, and cheaper than the “motorcycle” oil.
Same, works great!
Honestly that looks nothing like the outlaw 525 engine! That is the predator 500 engine. And both the IRS suspension outlaw chassis ATV's had the same platform engine.. one had an outlaw 525 while the other IRS outlaw had a predator 500 engine! It's totally possible that is the case here. It looks like the predator 500 engine in the outlaw chassis.
That's true, I should've checked that, your right
They come with Douglas wheels from the factory they're only the yellow label rims so they're the cheap ones they're not really worth much it's also missing the dual rate springs out of the front there should be too small springs on top of the larger springs
Looks like they're there. Just collapsed.
That’s a 500 motor not a 525. The 525 is made by KTM and says it on the side covers of the engine.
i had the ktm motor 525. thing ripped.
That’s most definitely a 525 outlaw
Unless someone replaced it because the predator had the 500 all outlaws have the 525 if I’m not mistaken
those machines work so well. and although 2wd they still rock in the trails because of the ground clearance
I REALLY LIKE WATCHING THE VINTAGE DUDE BECAUSE HE RELAXES ME SO MUCH!
This is the 500 not the 525 Ktm motor It’s Polaris 500 predator The 525 is called outlaw 525
Nice 4-wheeler I would take that jumper box with me on a test ride next time with the dead battery pretty good deal on this one
Run some gum out octane booster.& Gum out carb& choke cleaner shaken up in the bottle mixed together. The pour the measured amount for the gallons in your fuel tank.
This kid is wildly smart man I love these vids honestly
I got a Honda trx450er that needed a carb clean and that’s all it needed till 1st gear went out the first day I rode it and then the whole transmission 2 months later.
ah bummer! Almost got a great deal!
Yeah definitely I only paid $2400 so if the transmission wasn’t blown soon after it would have been perfect. Bonus is now it is completely built for the price of a working stock one.
You can try to push start quads that have reverse in reverse it tends to be easier to do that way. I have an ltz400 and if needed I'm able to start it in reverse.
I’m going to have to try that. I have been stuck a few times cause of a dead battery.
Just the inspiration I need to finish my 2007 ninja 250 build , get tyres this w/e and I have all the parts just have to spin some spanners get everything on 👍🏼👍🏼👍🏼👍🏼
You posted at a perfect time studyhally just started for me love the videos man keep up the great work!
That is the 500 outlaw. 525 came out in 2007. You can see it's the 500 predator engine
Wish people knew what they are taking about
Ask? I mean, the engine of the 2006 Outlaw 500 is the same engine that comes with the Predator. I mean, why have I searched for parts or spare parts for the Outlaw, but they almost don't appear, more of the Predator appear.
I don't recommend using the transmission type in your regular oil blends in though at all. Now in your 2 cycle oil yes cause it's made similar to that with more additives in the oils.
"it just needs a carb clean"....heard that a zillion times
Looks awesome man ... no doubt you will have it running in no time
Man actually washed something before working on it?? That's it the worlds gonna end 😂
2 turns on air fuel screw is plenty at your elevation.
That trail tech dash is nice I have one on my bike... worth a bit.
that’s a outlaw 500 not 525. the only outlaw to be produced in 2006 was a 500
You can add in some Lucas oil products for extra protection. Like Lucas oil stabilizer with h stop leak.
Check the swith up in the throttle lever..if tht ain't set correctly it will shut of..it's a safety roll over switch
Wet clutch oil setups will have pretty dark oil… it certainly needed changed but it’s not that out of the ordinary … nice find for the money. That’s a sharp
Looking quad
yep, I changed my outlaw's oil religiously and it gets real dark real fast, just how they are.
Good thing you Dad and Mom aren't lawn people lol, tearing it up all the time they must be pretty supportive.
awesome deal, great video!
at 31:40 when she flames out on you while its rolling, with some quick thinking you can quickly pop her back in 2nd gear and use your momentum to try restarting the engine. obviously if it stalled due to out of fuel it's not that helpful... but if it stalled from blipping the throttle and flaming out it should fire right back up.
Read up on that trailtech unit.i have one on my xr 650,and they have a ton of features.it also has an internal battery that you need to change about once a year.
First rule when you're selling something, CLEAN THE DAMN THING !! LOL
Lmaoo some couldn’t care less
Awesome content. Wish you were my neighbour. Very knowledgeable. Stumbled across your channel. Very entertaining.
the neutral light is the bulb. there should be a spare one in one of the other sockets. i had the same thing happen
They usually are..if its to good to be true.you know it is dude..especially now a days people scamming everyone
Those jump packs are made to jump start engines. Once the engine starts take it off asap. The charging system will ruin them. Not like the normal big jump pack that’s basically just a battery in a box
Boy oh boy your trouble shooting skills are increasing crazy fast, its fun to watch you work. great job man!
It’s definitely smoking when you ride great buy though
I used to have an 08 outlaw 525 and this is not the 525 unfortunately. It is the 2006 outlaw 500 with the same engine as the predator 500s
Definitely with you I had a 500 outlaw. Still a great quad just not the torque monster 525. That woodruff key is gonna be dust banging off that rev limiter smdh
I wonder if there's a neutral safety switch? That could go hand and hand with why the neutral light isn't working.
that's what he was talking about with the two bolts on the bottom side of the motor they have a switch in the motor and a wire connects to it to ground it when it's grounded the neutral light is on its common on Hondas and other some other bikes you just cut and ground that wire and the neutral light stays on works great in mud bikes you can start in any gear say your under the water in gear it dies you just fire it right back up assuming it's a honda you should be good to go
I wonder if he checked the light bulb first, probably not.
@@wisecampmotorcycles8258 looked like a back light led to me with the unit so thin and the bike only a few years old with the digital dash
@@jamesdougan8789 the digital dash is an aftermarket add on
There’s no better feeling than getting a bike that doesn’t run to run 💯
When somebody tells you a bike won't run, then you buy it from them cheap and get it running, you should always ride past them and wave...best feeling ever
You should try a leaf blower to dry it off before you start. Just a suggestion.
mine came stock from day I bought new at dealership in those same colors the reason Polaris did the orange frame and shocks is because that's the KTM 525 motor that's in it so the orange was like a tribute to ktm cuz Polaris provided ktm with the rolling chassis back then so ktm could get in the quad game which I also have one of KTM'S qauds from that era also
It’s a 500 not 525
I'm surprised that there's no kicker or pull cord recoil start on that machine. You could find an incline and bump start it,.....
Those have a low oil shutdown switch on em if I remember right and they're touchy.
I wonder if its burning oil. Its smoking when you ride it. Hope that's not an issue. (Unless oil was overfilled?) Looks like a good deal though!
Don’t have to worry about mosquitoes with that thing running!
Maybe the clutch is sticky when you stop it cuts out. Thinking your clutch is not full disengaging and stalling the motor
That's a great guy for not lying 👏
I’d keep that thing it’s pretty damn clean
Great location and lovely home 🏡
A lot of that stuff is probably wired into the trail Tech
How do you find deals like that.. I live in the Raleigh area of NC and can never find deals. They are literally ready for the dump at those prices lol
Brother in law had a brand new outlaw years ago, one of my favorite quads to ride to this day
Nice quad joe good deal for defo cleaned up nice pretty quick too good job man take care 🔧🔧👍👌🔧
Hell of a deal for that bike not to often you get a good one
Yeah not bad!
Sweet deal. Got really lucky on this one. Quick $1500 profit. Like to see a top speed run.
You can flip the rims around the other way and they'll be wider
I had this problem with my old ltz400 battery had a bad cell and it was sucking all the voltage she would pop and bang and die when you were trying to ride it
Neutral safety switch is bad, seen it before, might remove it and clean it up.
$15 hundred What a steal 🔥 BOOM 🔥 Dang right as you said that lol Crazy. That's about how my luck goes too bro. Soon as I brag on something it blows up in my face. 😆 Dang that sucks.
I got a question when you pull in the clutch to down shift do you have to let it go and then down shift again or can you pull it in and down shift thow all the gears
What happened to the 2007 yfz 450? Great vid by the way!
I'd check out the light bulb inside of that neutral safety switch spot. It just might be blown out is all that's wrong with it.
On the bad motors you should strain the old oil for metal or magnets 🧲
Love it wen I get a notification for your vids .. everything els gets dropped till iv watched 👀
Thanks for watching!
Check the fuse under the back fender mine went bad making the battery dead when i turned it off had to do the same thing
The oil is black af...bc u said u smelt gas in the oil...well the gas acted as tho a cleaner and cleaned the engine out so...ya got a nice engine flush lol luckily it didnt spin a bearing or wipe one out and fixed the carb....polaris makes some good equipment....one of these outlaws won the local line mountain 7 miler race 2 years in a row where I live...the irs I'm sure had alot to do with it
excellent video! i feel you ought to apologize to the seller for calling him a liar. lol
My first thought when I seen it all dirty is that it died in or on a trail and the guy selling it just brought it home and let it sit around
one of these days you need to et a 6x8 trailer with nice fold down ramp
I was going to get one of those. But ended up getting a 2008 TRX700XX It was a monster, very fast
Literally just saw this on Marketplace haha. Nice job Joe.
Good find. Sweet bike.
i had one of these. except mine had the 525 ktm motor. fast quad for what it is.
Love your videos man but you can't just keep calling every person you buy from a scammer.... Your just got like a 4000 dollar four wheeler for 1500 and dude said all it needed was a carb clean.. I watch the whole video and every few mins it's I hope I'm not getting scammed cuz it happens 🤷🤔 like I get it your right 110% but have some faith man not everyone's like that brother💯🙏 ❤️ keep up the awesome videos tho ☝️ and good job 👋🍻
I love these ktm 525 there bad ass great buy again Joe. You have the patience n knowledge to get it running as it should so let’s see what’s to come for this one 💪🏻
I love watching your vids you are a very talented young man keep it up mate
Score! What a winner. Love your videos man.
that carburator looks exactly same as my Goes 450 X carb. the only thing is i cant find anywhere spare parts/ rebuild kit in that, any advices?
if im right, its Mikuni BDS 42 carb
Were the indicator lights disconnected when they installed the aftermarket dash?
Dude i got a predator 500 and it’s doing a lot of black smoke even on iddle, what should i check? Hope you can help me
Honestly I watch a ton of ur vids you should creat ur own business and teach classes on how to rebuild shit, maybe charge 20/30 bucks a person I would 100000000 percent pay that to be taught to take carbs apart and shit like that. Dude you rock bro keep it up man
you should really get an ultrasonic cleaner machine for all those carbs
a great deal you got here !
Any idea why a quad would screech in a high gear at high speed? No clutch
I have a 525 KTM outlaw on a long hard ride the Clutch which is hydraulic loses It’s prime until it cools off. Any ideas?
Nice buy.
It's a wicked quad. 👍
Black/Orange is great color scheme
Finally a video where the bike gets cleaned first .. Hallelujah
Pretty sure that’s a ktm motor. Exc I believe. That’s a beast of a motor. Just needs to come out of that Polaris Frame and go in something good.
Polaris motor. 525 is KTM
I'm pretty sure what you have there is a 500 not a 525, but I could be wrong.
Yes your wrong outlaw was 525 ktm motor not the same as a predator 500
@@JohnDoe-ww2zf I do believe you are wrong. That is a fugi motor, not a ktm. Are you sure you even know the difference? They made 2 different outlaws.....a 500 and a 525, one with the fugi motor and one with the ktm. The engine side cases say polaris, if it was a 525 it would say KTM on the side cases. So before you go calling someone wrong maybe you should know your atvs.
I have both an outlaw 500 and an outlaw 525. Both are 2007 and both are irs.
My 525 is white and black. My 500 is grey and black.
@John Doe
@@bubbaflook8230 I hate it went people don’t know what there talking about. It’s clearly a 500 just by looking at the head
I have the same exact quad. 06 Polaris outlaw 500. Same axels, fox shocks, and all. Only difference is my fram is black lol. And grey seat
Yeah good deal n good job gittin it up n goin!!!
What oil would you say a 2012 400ex needs I’ve looked it up but