That last battery sounded quite tired. Wash the top of the battery, as a dirty battery helps with creep power. (Drains your batteries over time). Also if the starter motor cannot spin the motor fully, it needs charging, or replacing. I have a 8kW generator with the 192f engine in it and the starter is a 1,9kW unit, and it has a 95Ah Gel battery for starting. (See my video for the first run..) The starter howls when engaged, and spins my engine at 3 times the speed (without pressing the decomp-lever) faster than I can pull the pullstart (with the decop-lever held down).. I will make a cold-start video of my generator and upload this weekend.. Good quality fully synthetic engine oil is also a must for these small air cooled diesels. They run great on HVO or RME.
Decompression lever is there when you are using recoil start not Necessary for electric start however he went from one bad battery to another bad battery.
Around 15 minutes into the video you mentioned a corroded circuit board, well this is the very thing I would like to know about. It is the oil alert which stops the engine if it detects low oil pressure. I have two generators and both have had issues with this circuit caused by dry joints or wires falling off with all the vibration. I would be very grateful for a circuit diagram or an explanation of how this system works if anyone knows.
I bought a used Yanmar clone, and it came without the recoil starter. I bought one for it, but I haven't installed it yet. It also came from a generator. The engine was otherwise complete except for the muffler. I'll make one work on it.
This is nerve wracking. Ether can start but a gas engine sized blast can blow up inside like a grenade. No more ether/heptane. Your battery is insufficient. In cold weather, you pour hot water on the engine. Clean injector? Like surgery clean. Change the oil. Downthrottle it. It never needs a blast. In two three cranks, it should be starting up. A high idle is normal.
That last battery sounded quite tired. Wash the top of the battery, as a dirty battery helps with creep power. (Drains your batteries over time). Also if the starter motor cannot spin the motor fully, it needs charging, or replacing. I have a 8kW generator with the 192f engine in it and the starter is a 1,9kW unit, and it has a 95Ah Gel battery for starting. (See my video for the first run..) The starter howls when engaged, and spins my engine at 3 times the speed (without pressing the decomp-lever) faster than I can pull the pullstart (with the decop-lever held down).. I will make a cold-start video of my generator and upload this weekend.. Good quality fully synthetic engine oil is also a must for these small air cooled diesels. They run great on HVO or RME.
Next time push down the decompression lever, it will still get fuel to the top injector with no compression. It’ll save your battery and starter.
Liked your video but please be aware of the risks involved from blood poisoning from testing the injector that way. Never spray towards your hand!
Came here to make sure someone mentioned this!
You're turning the engine over on full compression. . There is a decompression lever right there!
He used the decompression lever
@@TheATVboy17 only after killing the battery
Decompression lever is there when you are using recoil start not Necessary for electric start however he went from one bad battery to another bad battery.
Around 15 minutes into the video you mentioned a corroded circuit board, well this is the very thing I would like to know about. It is the oil alert which stops the engine if it detects low oil pressure. I have two generators and both have had issues with this circuit caused by dry joints or wires falling off with all the vibration. I would be very grateful for a circuit diagram or an explanation of how this system works if anyone knows.
I bought a used Yanmar clone, and it came without the recoil starter. I bought one for it, but I haven't installed it yet. It also came from a generator. The engine was otherwise complete except for the muffler. I'll make one work on it.
eBay has tapered shaft adapters for this type engine. It's the simplest way to use this engine.
Weren't you tempted to put a drop of gas in the injector hole?
Please, the type of power, a special charging, the battery assistant
I have same problem,..
Solve with cam change
Επισης και οι ασιατες ειναιπολυ καλοι
Its a Honda 15kw generator, looks like mine
Ευτυχωςπουειναι οι ξενοι καιμαθαινουμε μερικα πραματσ
You better have daughter's with those painted nails lol
too much ether!
This is nerve wracking. Ether can start but a gas engine sized blast can blow up inside like a grenade. No more ether/heptane. Your battery is insufficient. In cold weather, you pour hot water on the engine. Clean injector? Like surgery clean. Change the oil. Downthrottle it. It never needs a blast. In two three cranks, it should be starting up. A high idle is normal.
It will only blow up if the motor has glow plugs that are on
@@billdepew9682 No. It happens easily. No more badly informed comments. OK ?
@@stanleybest8833 know what you are talking about next time
Clown!
Mechanic wrong😅😅😅